To Order Parts Call 1-888-702-5326 - https://monsterfloorequipmentparts.com
INSTRUCTIONS FOR USE
Blue 32
– 146 2301 000(1)2005-03
3
GENERAL SAFETY INSTRUCTIONS
Specific warnings and cautions to inform you about
potential exposure to bodily harm and machine damage
are listed below.
–
To perform maintenance/repair procedures turn the
machine ignition key to the OFF position and
disconnect the battery.
–
This machine must be used by qualified and
authorized personnel only. Children or disabled
people cannot use this machine.
–
Keep the battery far from sparks, flames and smoke.
Explosive gases are vented during normal operation.
–
Do not wear jewelry when working near electrical
components.
–
Do not work under the lifted machine if it is not
securely supported.
–
Do not operate the machine near dangerous,
flammable and/or explosive powders, liquids or
vapors.
–
Battery charging produces explosive hydrogen gas.
Keep the hood open during battery charging and
perform the operation only in well-ventilated areas
and far from open flames.
–
When wet (lead-acid) batteries are mounted on this
machine, do not tilt the machine more than 30° from
its horizontal position. Doing so could cause the
highly corrosive acid to leak out of the batteries.
When it is necessary to tilt the machine for
maintenance, remove the batteries.
–
Carefully read all maintenance/repair instructions
before carrying out any maintenance/repair
procedure.
–
Take all necessary precautions to prevent hair,
jewelry and loose clothing from being caught in
moving parts.
–
Do not smoke during battery charging.
–
Do not leave the machine unattended with the ignition
key inserted and the parking brake deactivated, if
equipped,.
–
Do not use the machine on surfaces with a gradient
greater than 2%.
–
Do not wash the machine with pressurized water, or
with corrosive substances. Do not use compressed
air to clean this type of machine.
–
Do not use the machine in extremely dusty areas.
–
During the use of this machine take care not to
endanger other people.
–
Storage temperature must be 32°F - +104°F
(0°C - +40°C).
–
The machine working temperature must be within
+32°F - +104°F (0°C - +40°C).
–
Humidity range should be within 30% and 95%.
–
Do not use the machine as a transport vehicle.
–
Do not allow the brooms to operate while the machine
is stationary to avoid damaging the floor.
–
In case of fire, use a powder extinguisher. Do not use
water.
–
Do not bump into shelves or scaffolding where there
is a risk of falling objects.
–
Adjust the operating speed according to the floor
conditions.
–
Do not tamper with the machine safety guards; follow
the ordinary maintenance instructions scrupulously.
–
Do not remove or modify the plates affixed on the
machine.
–
In case of machine malfunctions ensure that these
are not caused by a lack of maintenance. Otherwise,
request assistance from the authorized personnel or
a Service Center.
–
If parts must be replaced, request ORIGINAL spare
parts from a dealer or Authorized Retailer.
–
To ensure proper machine operation and safety
conditions, the authorized personnel or Service
Center must carry out the Scheduled Maintenance
detailed in the related chapter of this Manual.
–
The machine must be disposed of properly, at the end
of its cycle of life, because of the presence of
toxic-harmful materials (battery acid, oil, etc.), which
are subject to standards that require disposal in
special centers (see chapter “Scrapping”).
–
If the machine is used according to the instructions, it
will not produce dangerous levels of vibration. The
machine vibration level is below 2.5 m/s
2
.
UNPACKING
When the machine is delivered, check that the carton and
the machine were not damaged during shipping. If
damage is evident, keep the packing materials and have it
checked by the Parcel Service that delivered it. Call the
Parcel Service immediately to fill out a request for a
compensation for damages.
Please check that the following items have been supplied
with the machine:
1.
Technical documents: Sweeper Instruction for Use
Electronic Battery Charger Manual, Parts List
2.
Side broom fuse (1)
3.
Spare battery cables, terminal boots
4.
Electronics fuse (1)
DANGER!
WARNING!
