3
MAINTENANCE
MINIDUMPER
CARRY 107
30
3.3.4 BATTERY MAINTENANCE
1) Cleanliness
Clean the battery surface. Keep the terminals clean and coated with good quality grease. Install the post cover after
coating.
2) Battery recharge
Battery should not be allowed to stand in a fully discharged condition, but should be recharged as soon as possible. If
battery is out of use for a long time, it must not be allowed to run down completely. The battery should be given a
small recharge, sufficient to bring it back to fully charged state about every one or two months.
Trickle charging is not recommend and during charging as before, care must be taken that temperature of electrolyte
does not rise above 40 ºC for temperate climates and 52 ºC for battery using lower gravity acids specified for tropical
use.
3) Checks
Check the fluid level in all the battery elements or check that the level line in the battery is reached. Check the cells
once a week in extreme temperatures, battery fluid consumption may be higher.
4) Topping Up
Keep the fluid level immediately below the openings for topping up or, in any case, above the level indicated by the
level line, adding water when necessary. If part of the electrolytic fluid has been spilled, replace it with sulphuric acid
in the same concentration as that left in the battery.
The fluid level must never fall below the upper edge of the battery plates.
5) Disposal
Dead batteries must be disposed of as required by law.
3.3.5 LUBRIFICATION IN GENERAL
Lubricating the indicated parts when necessary as mentioned in “TABLE OF RECOMMENDED LUBRIFICATION”.
•
B
ATTERY GIVE OFF FLAMMABLE FUMES THAT CAN EXPLODE
.
•
D
O NOT SMOKE WHEN OBSERVING THE BATTERY ELECTROLYTE LEVELS
.
•
E
LECTROLYTE IS AN ACID AND CAN CAUSE PERSONAL INJURY IF IT
CONTACTS SKIN OR EYES
.
•
I
F THE ELECTROLYTE COMES IN CONTACT WITH EYES
,
WASH IT AWAY
WITH WATER AND CALL FOR EMERGENCY MEDICAL CURE
.
•
A
LWAYS WEAR PROTECTIVE GLASSES WHEN WORKING WITH BATTERY
.
WARNING
Pb
Содержание CARRY 107
Страница 2: ......
Страница 52: ...TRACKED MINIDUMPER CARRY 107 PUBLISHED MARCH 2017 KATO IMER S p A ITALY ...
Страница 53: ......
Страница 54: ......