AIRBLADE® DRYER
Mix and Match
116
Belanger, Inc. * 1001 Doheny Ct. * Northville, MI 48167 * Ph (810) 349-7010 * Fax (810) 380-9681
1MANUL011
Maintenance
Motor Maintenance Supplied by Baldor®
Section 1 General Information
Overview
This manual contains general procedures that apply to Baldor Motor products. Be
sure to read and understand the Safety Notice statements in this manual. For your
protection, do not install, operate or attempt to perform maintenance procedures until
you understand the Warning and Caution statements. A Warning statement
indicates a possible unsafe condition that can cause harm to personnel. A Caution
statement indicates a condition that can cause damage to equipment.
Important:
This instruction manual is not intended to include a comprehensive listing of
all details for all procedures required for installation, operation and
maintenance. This manual describes general guidelines that apply to most of
the motor products shipped by Baldor. If you have a question about a
procedure or are uncertain about any detail, Do Not Proceed. Please contact
your Baldor distributor for more information or clarification.
Before you install, operate or perform maintenance, become
familiar with the following: S NEMA Publication MG-2, Safety
Standard for Construction and guide
for Selection, Installation and Use of Electric Motors and Generators. S The
National Electrical Code S Local codes and Practices
Limited Warranty
1.
1.
Most Baldor products are warranted for 18 months from the date of shipment to
Baldor’s customer from Baldor’s district warehouse or, if applicable, from Baldor’s factory. Baldor
Standard
−
E® standard efficient motors are warranted for 24 months. Standard
−
E is limited to three
phase, general purpose, 1
−
200 HP ratings that fall under the Energy Policy Act (EPAct). Baldor
Super
−
E® premium efficient motors are warranted for 36 months. Baldor IEEE841 motors are
warranted for 60 months. All warranty claims must be submitted to a Baldor Service Center prior to
the expiration of the warranty period.
.2.
Baldor will, at its option repair or replace a motor which fails due to defects in material or
workmanship during the warranty period if:
.a.
the purchaser presents the defective motor at or ships it prepaid to, the Baldor plant in Fort
Smith, Arkansas or one of the Baldor Authorized Service Centers and
.b.
the purchaser gives written notification concerning the motor and the claimed defect including
the date purchased, the task performed by the Baldor motor and the problem encountered.
1.
3.
Baldor will not pay the cost of removal of any electric motor from any equipment, the
cost of delivery to Fort Smith, Arkansas or a Baldor Authorized Service Center, or the cost of any
incidental or consequential damages resulting from the claimed defects. (Some states do not allow
the exclusion or limitation of incidental or consequential damages, so the above exclusion may not
apply to you.) Any implied warranty given by laws shall be limited to the duration of the warranty
period hereunder. (Some states do not allow limitations on how long an implied warranty lasts, so
the above limitation may not apply to you.)
2.
4.
Baldor Authorized Service Centers, when convinced to their satisfaction that a Baldor
motor developed defects in material or workmanship within the warranty period, are authorized to
proceed with the required repairs to fulfill Baldor’s warranty when the cost of such repairs to be paid
by Baldor does not exceed Baldor’s warranty repair allowance. Baldor will not pay overtime premium
repair charges without prior written authorization.
