use and maintenance
TUONO 1000
USA
10
9
10
11
12
13
Ref.
Description
-Wear a helmet, eye protection, and bright protective clothing.
-Don't ride after consuming alcohol or other drugs.
-Slow down on slippery surface, unfamiliar terrain or when visibility is reduced.
- Read owner's manual carefully.
-Failure to follow these warnings can lead to an accident and serious injuries or death.
-USE UNLEADED FUEL MINIMUM OCTANE RATING (R + M) / 2 METHOD 90.
- See owner's manual for the correct running in and maintenance of the vehicle.
Do not allow key chain and any other
item to fall between the steering head and the body of motorcycle.
This can cause loss of control.
Do not use any tire other than those reccomended and approved by Aprilia. Maintain
proper tire inflation. Do not use any tire with less than 1/8" (3mm) tread remaining.
Do not repair any tire, nor use repaired tire. Do not ride your motorcycle overloaded
or with an unbalanced load. Failure to follow these warnings can lead to an accident
and serious injures or death. Always ensure that the chain is correctly adjusted.
See owner's manual.
(36)
280
(41)
230
250
(36)
250
(33)
250
(36)
280
190/55 ZR 17"(75W)
(41)
(58W)
Pirelli - Metzler
Michelin
Dunlop
Pirelli - Metzler
Michelin
Dunlop
RRT
(56W)
(73W)
(73W)
kpa - (psi)
MOTORCTCLE NOISE EMISSION CONTROL INFORMATION
THIS 2007 ASPRRT0998 MOTORCYCLE. ZD41016 MEETS EPA NOISE EMISSION
REQUIREMENTS OF 80 dBA AT 5225 closing r.p.m. BY FEDERAL TEST PROCEDURE.
MODIFICATIONS WHICH CAUSE THIS MOTORCYCLE TO EXEED FEDERAL NOISE
STANDARDS ARE PROHIBITED BY FEDERAL LAW.
SEE OWNUER'S MANUAL.
RRTT
RRT
VEHICLE EMISSION CONTROL INFORMATION
ENGINE DISPLACEMENT: 998 cc
ENGINE FAMILY: 7ASPC0.99RRT
THIS VEHICLE CONFORMS TO U.S. EPA AND CALIFORNIA
REGULATIONS APPLICABLE TO 2007 MODEL YEAR
NEW MOTORCYCLES AND IS CERTIFIED TO
0.8 HC+NOx G/KM ENGINE FAMILY EXHAUST
EMISSION STANDARD IN CALIFORNIA.
ENGINE EXHAUST CONTROL
SYSTEM: HO2S-2TWC-
SFI
ENGINE TUNE UP SPECIFICATIONS
IGNITION TIMING: 23.2˚ ± 2˚ AT 2800 RPM
IDLE SPEED: 1250 ± 100 RPM IN NEUTRAL
VALVE CLEARANCE:
INLET 0.0047÷0.0067 inch (0.12÷0.17 mm)
OUTLET 0.0091÷0.0110 inch (0.23÷0.28 mm)
SPARK PLUG: NGK R DCPR9E
FUEL: MINIMUM OCTANE RATING (M+R)/2 METHOD 90
OIL: ENGINE OIL VISCOSITY SAE 15W-50
PART 575.6, CONSUMER INFORMATION
14
Muffler stamping.
Ref.
Description
aprilia
World Service USA, Inc.
109 Smoke Hill Lane Suite 190 GA, 30188 Woodstock
Reporting Safety Defects
If you believe that your vehicle has a defect which could cause a crash or could cause
injury or death, you should immediately inform the National Highway Traffic Safety
Administration (NHTSA) in addition to notifying
aprilia
World Service USA, Inc.
If NHTSA receives similar complaints, it may open an investigation, and if it finds that a
safety defect exists in a group of vehicles, it may order a recall and remedy campaign.
However, NHTSA cannot become involved in any individual problems between you,
your dealer, or
aprilia
World Service USA, Inc.
To contact NHTSA you may either call the Auto Safety Hotline toll-free at 1-888-327-4236
or write to:
NHTSA
U.S. DEPARTMENT of TRANSPORTATION
400 7th Street SW, (NVS-223) Washington, DC 20590
You can also obtain other information about motor vehicle safety from the Hotline.
APRum_TUONO_MY05_####.book Page 10 Monday, January 9, 2006 2:53 PM
