Wallace & Tiernan SERIES V-2000, Manual

Page: 19 / 132

6
WT.025.055.004.UA.IM.0814
MANUAL CHLORINATOR - 3000LB/24HR
EVOQUA W3T109620
WARNING: THIS CONTROL MODULE IS DESIGNED TO OPERATE UNDER
VACUUM ONLY. TO AVOID POSSIBLE SEVERE PERSONAL INJURY OR
EQUIPMENT DAMAGE, DO NOT CONNECT TO A SOURCE OF GAS UNDER
PRESSURE.
2.1 Location of Components
The general physical requirements of the installation are shown on the Typical
Installation drawings. Locate the control module so that the necessary gas and
power supplies may be connected. Ready access to the equipment for opera-
tion, routine maintenance, and service is required. Locate the injector so that
the water supply, solution line to the point of application, and suction lines are
connected with access for service conveniently provided.
2.2 Gas Supply
For gas supply installation details, refer to the separate instruction book
provided with the vacuum regulator (which regulates the gas supply to the
control module).
2.3 Unpacking
When the equipment and accessory items are unpacked, check all items against
the packing list to be sure that no parts are discarded with the packing material.
Whenever possible, unpack the equipment at the installation site. Set aside
items not required at the time of installation, such as spare parts, where they
will be available when needed.
WARNING: TO AVOID POSSIBLE SEVERE PERSONAL INJURY OR EQUIP-
MENT DAMAGE, DO NOT DISCARD OR REMOVE THIS INSTRUCTION BOOK
WHEN THE INSTALLATION IS COMPLETED. THE OPERATOR WILL NEED IT.
CAUTION: To prevent damage to the module, replace the shim washers
underneath the module after the plywood feet are removed.
2.4 Pressure Relief Valve
WARNING: TO AVOID POSSIBLE SEVERE PERSONAL INJURY OR EQUIPMENT
DAMAGE, A PRESSURE RELIEF VALVE MUST BE INSTALLED THE SYSTEM.
NOTE: See appropriate Typical Installation drawings.
2.5 Rotameter
For protection in shipment, the rotameter and associated parts are removed
after the gas feeder is factory tested. These parts are separately packaged;
assemble and install as indicated on Dwg. 25.055.151.010.
!
!
!
!