Model: 2295-10PR (9694-010)
95 Ton (86 Metric Ton) Alligator Axle Jack
01/2019 | Rev. 01
Page | 2
3.0
PREPARATION PRIOR TO FIRST USE
3.1
GENERAL INSPECTION
If the jack is crated, uncrate and remove shipping straps or packing material. Inspect for physical damage and missing parts.
3.2
BLEED PROCEDURE
1. Loosen hydraulic line at base of cylinder.
2. Raise rain hat off cylinder.
3. Operate hand pump and air pump until oil comes out freely with no air bubbles. Tighten hydraulic line at base of cylinder.
4. Using air pump, cycle cylinder rams several times. If air pump has lost its prime and will not raise cylinder rams, perform
Steps 5 thru 10. If air pump will raise cylinder rams, go to Step 11
5. Open release valve.
6. Remove reservoir filler plug.
7. Wrap an air nozzle with rags and stuff into fill plug port.
8. Pressurize reservoir with air (maximum 25-30 psi) and slowly close release valve.
9. While pressurizing reservoir, operate air pump until rams in cylinder begin to extend.
10. Stop pressurizing reservoir and verify that the air pump continues to raise cylinder rams.
11. Remove air nozzle from reservoir, check fluid level and replace filler plug.
12. Using hand pump, cycle cylinder rams several times.
13. Replace rain hat on cylinder.
4.0
TRAINING
4.1
TRAINING REQUIREMENTS
The employer of the operator is responsible for providing a training program sufficient for the safe operation of the unit.
4.2
TRAINING PROGRAM
The employer provided operator training program should cover safety procedures concerning use of the unit in and around the
intended aircraft at the intended aircraft servicing location.
4.3
OPERATOR TRAINING
The operator training should provide the required training for safe operation of the unit.
NOTE: Maintenance and Trouble Shooting are to be performed by a skilled and trained technician.
Summary of Contents for Columbus Jack 2295-10PR
Page 2: ...REVISION DATE TEXT AFFECTED 01 01 2019 Original release ...
Page 26: ......
Page 27: ...APPENDIX I Routine Jack Maintenance Bulletins ...
Page 28: ......