![background image](http://html1.mh-extra.com/html/thermo-king/919180/919180_manual_1104379130.webp)
Electric Standby (Optional) Diagnosis
130
Contact chatter
Low battery voltage
Check voltage condition. Check
momentary voltage dip during
starting—low voltage prevents
magnet sealing
Defective or incorrect coil
Replace coil
Poor contact in control circuit
Check auxiliary switch contacts and
overload relay contacts. Check for
loose connections in control circuits
Contact welding or freezing
Abnormal in-rush of current
Check or grounds, shorts or
excessive motor load current
Low voltage
Correct voltage condition. Check
momentary voltage dip during
starting
Foreign matter prevents contacts
from closing
Clean contacts
Rapid cycling
Check for cause of short cycling
(such as thermostat)
Short circuit
Correct fault
Electric heaters do not heat—
(optional) indicator lights come
on
Defective heater contactor
Replace contactor
HC wire open
Locate open and repair
Battery is not recharging
Loose connections in electrical
system
Check all electrical connections and
charging system
Worn brushes in alternator
Replace brushes
Voltage regulator faulty
Repair or replace regulator
Battery defective
Replace battery
Alternator defective
Repair or replace alternator
Loose belt
Tighten belt
Dirty battery terminals
Clean and retighten
Alternator relay defective
Replace relay
Fuse F309 open
Replace fuse
Condition
Possible Cause
Remedy
Summary of Contents for 919180
