Mechanical Diagnosis
126
Engine stops after starting
Air in injection pump
Bleed fuel system
Fuel filter obstructed
Replace filter element
High water temperature coolant
Add coolant. Check for leaks
Low oil pressure
Add oil. Check for leaks
Vent of fuel tank obstructed
Remove obstruction
Electric fuel pump not operating
Check pump for running and 8 to
10 psig (55 to 69 kPa). Repair or
replace fuel pump
Dry air cleaner plugged
Change filter element
Fuel solenoid not energized
Check run circuit
High refrigerant pressure
Locate and correct cause
Engine does not reach full power
Air or dirt in fuel system
Adjust
Fuel line leaks
Tighten connections of fuel lines. If
necessary, replace damaged lines
Speed adjustment wrong
Adjust speed
Electric fuel pump does not run
Check voltage. Repair or replace
pump
Fuel filter blocked
Install new filter
Electric fuel pump filter dirty
Clean and replace diesel filter
Delivery of fuel pump insufficient
Repair or replace pump
Cylinder head gasket leaking
Replace gasket
Piston rings worn, stuck or broken
Replace rings
Cylinder worn
Replace or bore
Leaking injection nozzle or irregular
injection caused by fouling
Clean and repair nozzle
Insufficient compression pressure
due to faulty piston or valves
Check cylinder with compression
tester. If necessary, grind valves or
replace piston
Air filter clogged
Clean air filter
Fuel tank vent clogged
Unclog vent
Injection rate too low
Adjust pump discharge rate
Insufficient injection pressure
Readjust or replace nozzle
Pump injects too early or too late
Adjust injection pump timing
Air in fuel system
Bleed fuel system
Air is drawn into fuel pump
Check all fuel lines and fittings
Loose governor assembly
Check and repair governor
assembly
Restricted exhaust system
Clean or replace restricted parts
Condition
Possible Cause
Remedy
Summary of Contents for 919180
