52
Electrical System
WARNING
WARNING
DANGER
Check the electrolyte level in the batteries regu-
larly and add distilled water as necessary. If the
batteries are frequently charged by the automatic
battery charger, the electrolyte level will have to
be checked more often. The correct fluid level in
the cells is usually approximately 1/4 to 1/2 inch
above the plates. If fluid is needed, fill to the
proper level with distilled water. Do not over fill!
NOTICE:
Some batteries are sealed and do not require
or allow the inspection of the electrolyte.
Keep the battery tops clean and dry. Dirt and
water can conduct electricity from one post to the
other causing the battery to discharge.
The battery posts should be kept free of corrosion.
Remove the cables and clean the posts and cable
clamps with a battery post cleaner or sandpaper
as required. Coating the battery posts and cable
clamps with petroleum jelly or silicone grease will
protect them and reduce corrosion.
Battery cables, both hot and ground, must be
replaced when they show signs of corrosion or
fraying. Deteriorated cables cause a considerable
voltage loss when high currents are drawn, as for
starting the engine or operating the bow thruster.
NEVER USE AN OPEN FLAME IN THE BATTERY STORAGE
AREA. AVOID STRIKING SPARKS NEAR THE BATTERY. A
BATTERY CAN EXPLODE IF A FLAME OR SPARK IGNITES
THE HYDROGEN GAS THE BATTERY EMITS WHILE BEING
CHARGED.
AC Electrical System Maintenance
Periodically inspect all wiring for nicks, chafing,
brittleness, improper support, etc. Examine the
shore power cord closely for cracks in the insula-
tion and corrosion in electrical connectors. Spray-
ing receptacles and electrical connections with an
electrical contact cleaner or a metal and electrical
protector will reduce corrosion and improve elec-
trical continuity.
Inspect all wiring for proper support, sound in-
sulation and tight terminals, paying particular
attention to portable appliance cords and plugs.
The entire AC circuitry, especially the shore power
cords, should be seasonally tested for proper
continuity by an experienced electrician. This will
detect any shorts, open wires, or ground faults.
Ground fault interrupts should be tested periodi-
cally to ensure proper operation by pressing the
test/reset buttons in the center of the face plate.
The polarity indicator system also should be in-
spected for proper operation.
Generator Maintenance
The engine maintenance required on the genera-
tor is similar in many ways to main 4-stroke out-
board engines. The most important factors to the
generator’s longevity are proper ventilation and
maintenance of the fuel system, cooling system,
lubrication system and the AC alternator.
The seawater cooling system is equipped with
a sacrificial anode and that should be checked
whenever the generator is serviced and replaced
as necessary. Maintenance schedules and pro
-
cedures are outlined in your generator owner’s
manual. They should be followed exactly.
CORROSION ALLOWED TO BUILD ON THE ELECTRICAL
CONNECTORS CAN CAUSE A POOR CONNECTION
RESULTING IN SHORTS, GROUND FAULTS OR POOR GROUND
CONNECTIONS. ELECTRICAL CONNECTORS SHOULD BE
CHECKED AT LEAST ANNUALLY AND CLEANED AS REQUIRED.
DO NOT ALLOW CORROSION TO BUILD ON CONNECTIONS.
ELECTRIC SHOCK CAN CAUSE SEVERE INJURY OR EVEN
DEATH. THE AC AND DC ELECTRICAL SYSTEMS ALWAYS
SHOULD BE DISCONNECTED FROM THE POWER SOURCE
BEFORE INSPECTING OR SERVICING THE SYSTEM. NEVER
SERVICE ANY COMPONENT OF AN ELECTRICAL SYSTEM
WHILE IT IS ENERGIZED.
Summary of Contents for 350 LXF
