SECTION 1
4
SAPPHIRE SCIENTIFIC MODEL 370 SS
®
PART#
49-038 REV F
15.
DO NOT
damage the vehicle in any way
during the installation. When routing fuel lines
DO NOT
configure the hose in any locations
where the hose or vehicle could be damaged.
Avoid contact with moving parts, hot surfaces,
brake lines, fuel lines, catalytic converters,
exhaust pipes, mufflers or sharp objects.
16.
NEVER
cut or splice any of the vehicle
fuel lines during fuel line installation. This will
result in fuel leaks and potentially dangerous
conditions. Use only the provided fuel hose for
fuel lines. When going through the vehicle
floor with fuel lines, always utilize bulkhead
adaptors. This will prevent fuel leaks and
ensure that hoses are not punctured by vehicle
vibration abrasion.
17.
DO NOT
exceed your vehicles weight
limit. The standard 370 installation weighs
approximately 1000lbs with an operating
weight of over 1600lbs. Make certain that the
vehicle has the correct axle rating. This will
prevent unsafe or hazardous driving conditions.
18. High back seats are required for all vehicles
that units are to be installed for head and neck
protection. Metal partitions between the seats
and equipment are strongly recommended.
19.
DO NOT
operate this unit without the
water supply on and attached. The water pump
and other vital components could be seriously
damaged if the unit is operated dry. This unit is
equipped with a low pressure shut down
switch, which should
NOT
be bypassed.
20. Always keep your vehicle clean and
orderly. Wands, tools and accessories must be
securely stowed while driving the vehicle.
21. All high-pressure hoses must be rated at
3000 PSI and have a heat rating of 250 degrees
F. Thermoplastic hoses do not meet this criteria
and should never be used. Severe burns and
other injuries could result if hoses do not meet
these requirements.
22. Ensure that you have received proper
training from the distributor that you purchased
the unit from prior to operation.
23. This unit produces high pressure and high
temperatures. Improper use could result in
serious injury.
24.
DO NOT
modify this unit in any manner.
Any modification could result in serious injury
or fatality.
25. California Proposition 65 Warning: Engine
exhaust from this product contains chemicals
known by the State of California to cause
cancer, birth defects, or other reproductive
harm.
Summary of Contents for 370 SS
