SECTION 4
28
SAPPHIRE SCIENTIFIC MODEL 370 SS
®
PART#
49-038 REV F
VACUUM PUMP
NOTE:
Refer to the provided Vacuum Pump
Operation and Service Manual for specific
instructions.
Lubriion: SAPPHIRE SCIENTIFIC
recommends that you use only AEON PD-XD
Synthetic Blower Lubricant in both sides of the
vacuum pump for all operating temperatures.
AEON PD-XD is formulated specifically for
positive displacement blower service to provide
maximum blower protection at any temperature.
NOTE:
AEON PD-XD (Part # 13-004)
is the
only oil that
SAPPHIRE SCIENTIFIC
puts in
the vacuum pump at the factory. Adding
petroleum oil to synthetic oil is
NOT
recommended.
1. Check the oil level
daily
on both sides to
ensure they are at the proper level. Too little oil
will damage and ruin the bearings and gears.
Too much oil will result in overheating.
2. A lubrication cup has been provided at the
front of the console, to prevent rust from
building up inside of the vacuum pump.
Run the unit for at least
2 minutes
to remove
any moisture from the vacuum pump. Then,
spray WD-40 (or Equivalent) into the
lubrication cup for
5 seconds
while the unit is
running and the vacuum inlet port is sealed.
This procedure should be done at the end of
every working day
.
3. Drain, flush and replace the oil every
100
hours or six months, whichever comes first.
NOTE:
Two drains are on your vacuum pump.
Ensure that both sides of the vacuum pump are
filled to their proper level when servicing.
WATER PUMP
Refer to the provided Water Pump Operation
Manual for specific instructions.
1.
Check the crankcase oil level
daily
to
ensure the proper level. If the level has
dropped, check for the source of leakage
and repair.
2. After the first
50 hours
of operation, change
the crankcase oil with Industrial Pump Oil, (Part
# 13-030). Change the crankcase oil every
500
hours
thereafter.
Oil Filter Cap
Oil Level
Sight Gauge
Oil Drain
Vent Cap/
Oil Fill
Oil Level
Sight Gauge
Oil Drain
Located Under
the Blower
Summary of Contents for 370 SS
