RCS20 M:N Redundancy Switch
Installation
TM056 - Rev. 2.3
2-1
Section 2 – Installation
2.0 Installation Requirements
This chapter instructs the user in the methods for setting up and installing an RCS20 M:N
Redundancy Switch into a Satellite Modem system. The cabling configurations for up to nine
channels and nine transponders are described.
2.1 Unpacking the System
Unseal the shipping cartons taking care not to damage the cartons, the packing material or the
equipment inside. The cartons and the packing material should be saved in the event that an
RCS20 will need to be reshipped. Examine the exterior of the units for any possible shipping
damage.
2.1.1 List of Items
Carefully remove the units from the cartons. In addition to this manual, verify that the following
items are present:
•
RCS20 Redundancy Control Unit
•
IFS20 or IFS20A Intermediate Frequency Switch
•
2 ea. AC Power Cords
•
2 ea. Bank Control 15-pin HD Sub Cables
•
M:N Switch System Test Data Sheet
•
M:N Switch to Modem Cable(s) for Backup Modulator and Demodulator
•
Test I/O Mating Connector
•
Optional 1:N Switch to Modem, I/O and Coaxial Cables for Modems 1 – 9
•
Optional Modem bypass cable(s) for Modems 1 – 9
2.1.2 In Case of Shipping Damage
If any shipping damage is discovered to any of the above listed equipment, promptly contact the
transporter and file a damage claim. The transporter is responsible for any damage caused during
shipping. Radyne, Inc. should also be contacted.
Damage as a result of transport is not covered under the Radyne, Inc. Warranty. Refer to the
Warranty section in the front of this manual for further information.
The procedure for returning faulty or damaged equipment is contained in the warranty section in the
front of this manual.
2.1.3 Test Data Sheet
Each RCS20 M:N Redundancy Switch system is shipped with a Test Data Sheet. This report
contains information on the results of the Switch quality control testing. The report also includes
information pertaining to the system settings that were made at the factory. Radyne, Inc.
recommends that the user save this report for future reference.
Summary of Contents for RCS20
