Nilfisk-Advance 56507009, Troubleshooting Manual

Page: 14 / 82

14 - FORM NO. 56043129 - SR 1900
Copyright 2007 Nilfisk-Advance.
Page 1 of 2
2/21/2007
SR 1900
PM Checklist
Defect Codes
Customer
A needs adjustment
B binding
Address
C dirty or contaminated
D damaged, bent or torn
City
St Zip L leaks
M missing
Model
Serial Hours W worn out
Ref
OPERATIONAL INSPECTION ITEMS
OK
Defect Codes
(circle)
Does
Not
Work
1 Check Neutral Safety/Sense Switch operation (To test depress drive pedal and start the
engine, it should not start.)
A B C
2 Engine Starting with pedal in neutral (if it will not start check sensor switch
programming)
starts hard
3 Engine Speeds 4 cyl G/P (1200 - 2400 RPM) A low power
4 Engine Speeds Diesel (note electrical actuator linkage 1200 - 2400 RPM)
5 Drive Pedal Linkage (check for FWD/REV drive and any neutral creep) A B
6 Drive System Performance noisy sluggish
7 Brakes (check both service & parking) A B W
8 Steering excessive play
9 Hopper Up/Down (also check operation of the safety hopper support) A B
10 Hopper Dump Door Open/Close A B
11 Main Broom Raise /Lower <----->
12 Side Broom Raise /Lower <----->
13 Main Broom On/Off <----->
14 Side Broom On/Off <----->
15 Headlights, Gauges and Optional Accessories (example rotating beacon, backup alarm)
16 Dust Control Filter Shaker & Vacuum Impeller
<----->
17 Tilt Steering Mechanism and Seat Adjustment lever A B
18 Dust Guard (OPT) Water Pump Operation On/Off
Ref
VISUAL INSPECTION ITEMS
Comments OK
Defect Codes
(circle)
Does
Not
Work
19 Side Broom Pattern & Height Adj. (min bristle wear 3 inches) 3 O'clock to 11 A B D W
20 Side Broom Motor B L
21 Hopper Cover Gasket D W
22 Hopper Dust Filter & Gasket D W
23 Dust Control Vacuum Impeller Motor L
24 Hopper Dump Door Cylinder A B L
25 Hopper Skirting & Seals (raise hopper to inspect) D M W
26 Hopper Dump Door & Seal (raise hopper to inspect) A B D W
27 Hopper Lift Cylinder & Hopper Interlock Switch Magnetic Switch A B L
28 Main Broom Pattern Adjustment (min bristle wear 2-1/2"
6.4cm length)
2-3" (5-7 cm) wide
pattern
A B D W
29 Main Broom Motor (open left side access door to inspect) B L
30 Broom Housing & Door Skirts D M W
31 Front tires (check lug nut torque 80FT LB, 108 Nm) Tire Pressure 90 psi L W
32 Battery Clean & Water C W
33 Engine Air Cleaner Element (inner & outer) Check SVR Indicator C W