PAGE 50 — DCA-220SSJ/SSJU — OPERATION AND PARTS MANUAL — REV. #0 (02/04/14)
Day-to-day addition of coolant is done from the recovery
tank. When adding coolant to the radiator,
DO NOT
remove
the radiator cap until the unit has completely cooled. See
Table 12 for engine, radiator, and recovery tank coolant
capacities. Make sure the coolant level in the recovery tank
is always between the "
H
" and the "
L
" markings.
Operation Freezing Weather
When operating in freezing weather, be certain the proper
amount of antifreeze (Table 13) has been added.
Cleaning the Radiator
The engine may overheat if the radiator fins become
overloaded with dust or debris. Periodically clean the radiator
fins with compressed air. Cleaning inside the machine is
dangerous, so clean only with the engine turned off and the
negative
battery terminal disconnected.
Air Cleaner
Periodic cleaning/replacement is necessary. Inspect it in
accordance with the
John Deere Engine Owner's Manual.
Fan Belt Tension
A slack fan belt may contribute to overheating, or to
insufficient charging of the battery. Inspect the fan belt for
damage and wear and adjust it in accordance with the
John
Deere Engine Owner's Manual.
The fan belt tension is proper if the fan belt bends 10 to 15
mm (Figure 36) when depressed with the thumb as shown
below.
Figure 36. Fan Belt Tension
DCA-220SSJ/SSJU — SETUP
If adding coolant/antifreeze mix to the
radiator,
DO NOT
remove the radiator cap
until the unit has completely cooled. The
possibility of
hot!
coolant exists which
can cause severe burns.
WARNING - BURN HAZARDS
NEVER
place hands near
the belts or fan while the
generator set is running.
CAUTION - ROTATING PARTS
e
z
e
e
r
F
-
i
t
n
A
.
3
1
e
l
b
a
T
s
e
r
u
t
a
r
e
p
m
e
T
g
n
i
t
a
r
e
p
O
%
l
o
V
e
z
e
e
r
F
-i
t
n
A
t
n
i
o
P
g
n
i
z
e
e
r
F
C
°
F
°
0
5
7
3
-
4
3
-
Coolant (Antifreeze)
John Deere recommends Antifreeze/Summer Coolant for use
in thier engines, which can be purchased in concentrate (and
mixed with 50% demineralized water) or pre-diluted. See
the
John Deere Engine Owner's Manual
for further details
y
t
i
c
a
p
a
C
t
n
a
l
o
o
C
.
2
1
e
l
b
a
T
r
o
t
a
i
d
a
R
d
n
a
e
n
i
g
n
E
)
s
r
e
ti
l
4
2
(
.l
a
G
4
.
6
k
n
a
T
e
v
r
e
s
e
R
)
s
r
e
ti
l
9
.
1
(
s
t
r
a
u
Q
2
When the antifreeze is mixed with water, the antifreeze
mixing ratio
must be
less than 50%.
NOTICE
Summary of Contents for Power WHISPERWATT DCA-220SSJ
