![background image](http://html1.mh-extra.com/html/multiquip/ca4hc-whiteman-series/ca4hc-whiteman-series_operation-manual_1855055055.webp)
CA4HM WALK-BEHIND TROWEL — OPERATION MANUAL — REV. #3 (10/28/10) — PAGE 19
Fuel Check
V-Belt Check
A worn or damaged V-belt can adversely affect the performance
of the trowel. If a V-belt is defective or worn simply replace the V-
belt as outlined in the maintenance section of this manual.
Belt Guard Check
Check for damage, loose or missing hardware.
Blade Check
Check for worn or damaged blades. Check to see if one blade is
worn out while the others look new. If this is the case there could
be a blade pitch problem. Refer to the maintenance section of
this manual for blade pitch adjustment procedure. Replace any
worn blades.
Hand Clutch
This finisher model is equipped with a
hand operated clutch
.
The unit automatically stops rotating when the clutch lever is
released. Clutch operation should be tested each time the machine
is started.
DO NOT
let the machine sit unused with the engine at high speed
for an extended period of time. It will cause premature belt wear
or may destroy the belt. Always set the engine speed to idle when
the hand clutch is disengaged.
1. Remove the gasoline cap located on top of fuel tank.
2. Visually inspect to see if fuel level is low. If fuel is low, replenish
with unleaded fuel.
3. When refueling, be sure to use a strainer for filtration.
DO
NOT
top-off fuel. Wipe up any spilled fuel.
2.
If lubrication oil begins to seep out as the drain plug is
being removed, then it can be assumed that the gearbox
has a sufficient amount of oil.
3.
If lubrication oil does not seep out as the drain plug is
being removed, fill with
type ISO 680 (P/N 10139)
gearbox
lubricant oil until the oil filler hole overflows.
Figure 7. Gearbox
Gearbox Oil
1.
Determine if the
gearbox
oil is low by removing the oil
plug located on the side of the gearbox. This plug will be
marked by the "
check
" decal. See Figure 7. The correct
level of the lubrication oil should be to the bottom of the fill
plug.
INSPECTION
EXPLOSIVE FUEL!
Motor fuels are highly flammable and can
be dangerous if mishandled.
DO NOT
smoke while refueling.
DO NOT
attempt to
refuel the trowel if the engine is
hot!
or
running
.
DANGER
Disconnect the spark plug wire from the spark plug and
secure away from the engine before performing
maintenance or adjustments on the machine.
CAUTION
NEVER
attempt to override the manual clutch by using
tape or other means to hold down the clutch lever. Doing so
may cause
SEVERE INJURY.
WARNING