Metabo HPT EC 2610EA, Instruction Manual And Safety Instructions

Page: 13 / 40

English
— 13 —
WARNING:
Never clean fi lter element with a
fl ammable liquid or solvent.
CAUTION: Do not operate without the air intake
fi lter.
Filter element
Air intake fi lter
Fig. 10
NOTE: Replace the fi lter element when it becomes dirty.
2. Draining tank
Drain tank daily or after 4 hours of use. Open drain valve
and tilt compressor to empty accumulated water (Refer
to Fig. 9).
4. Maintenance chart:
MAINTENANCE CHART
PROCEDURE AFTER USE DAILY WEEKLY 300 HOURS
Check pump oil level ×
Oil leak inspection ×
Drain condensation in air tank(s) × ×
Inspect guards/covers ×
Check for unusual noise/vibration ×
Check for air leaks ×
Clean exterior of compressor ×
Inspect air intake fi lter ×
Check safety valve ×
Change pump oil ×
Replace fi lter ×
Drain the fuel tank and carburetor when the compressor is not in use more than 30 days.
As regards the engine, follow instructions in the engine manual.
3. Oil change-oil topping o ff
CAUTION: Over fi lling with oil will cause premature
compressor failure. Do not over fi ll.
(1) Within the fi rst 50 hours of operation, completely replace
the oil of the pumping element. Unfasten the oil drain
bolt on the crankcase, drain all the oil, and screw the bolt
back on (Refer to Fig. 1 and to Fig. 11).
Oil drain bolt
Fig. 11
Pour oil into the hole of the crankcase to the level
indicated on the oil sight glass (Refer to Fig. 4).
For oil replacement, follow the oil type chart (refer to
page 10).
(2) Check the oil level of the pumping element daily.
(3) Change the oil every 300 working hours or every
3 months
SERVICE AND REPAIRS
All quality compressors will eventually require servicing or replacement of parts because of wear and tear from normal use. To
assure that only authorized genuine replacement parts will be used, all service and repairs must be performed by a metabo HPT
AUTHORIZED SERVICE CENTER, only.
NOTE: Speci fi cations are subject to change without any obligation on the part of the metabo HPT.
00Book̲EC2610EA̲metabo.indb 13 00Book̲EC2610EA̲metabo.indb 13 2021/08/05 10:58:53 2021/08/05 10:58:53