Maritime Geothermal ATF-45, Installation And Service Manual

Page: 57 / 110

1-Jun-2018 Page 57 002000MAN-01
Date: Installer Signature: Homeowner Signature:
A total of three copies are required: one for the homeowner, one for the installer, and one to be sent to Maritime Geothermal Ltd.
Startup Record - ATF-Series Two-Stage R410a
Installation Site Startup Date Installer
City Company
Province Check boxes unless
asked to record
data. Circle units.
Model
Country Serial #
Customer Name Customer Phone #
PRE-START INSPECTION
Outdoor Unit
System is pressure tested, vacuumed and extra charge added (extra charge only if needed)
Access valves are open and caps securely fastened
Securely mounted >12” from building, fan outlet clear of obstructions
All inter-connect piping is insulated and properly supported
Wiring is neat and securely fastened
Ductwork
Ductwork is completed, dampers/ diverters are adjusted
Registers are open and clear of objects
Air filter and end cap are installed
Condensate drain is connected, properly vented, & free of debris
Plenum heater is securely fastened (if applicable)
Indoor Loop
(Hydronic)
All shut-off valves are open (full flow available)
Loop is full and purged of air
Loop static pressure psig kPa
Domestic Hot
Water
All shut-off valves are open, lines are full and purged
Desuperheater pump wire is disconnected
Electrical
High/low voltage connections are correct and securely fastened
Circuit breaker (or fuse) size and wire gauge for Heat Pump A Ga.
Circuit breaker (or fuse) size, wire gauge, and Plenum Heater size A Ga. kW
STARTUP DATA
Preparation
Voltage across L1 and L2, L1 and L3, L2 and L3 VAC
Air Heating
Mode (10
minutes)
Suction Pressure / Discharge Pressure psig kPa
Duct Return, Duct Supply, and Delta T In Out °F °C
Outdoor Air Temperature °F °C
Compressor L1 (black wire) current A
Domestic Hot Water functioning
Air Cooling
Mode (10
minutes)
Suction Pressure / Discharge Pressure psig kPa
Duct Return, Indoor Out, and Delta T In Out °F °C
Outdoor Air Temperature °F °C
Heating Mode
(10 minutes)
Suction Pressure / Discharge Pressure psig kPa
Indoor In (Hot In), Indoor Out (Hot Out), and Delta T In Out °F °C
Outdoor Air Temperature °F °C
Compressor L1 (black wire) current A