1
Magnum Baby Countryside
Corn/ Biomass / Wood Pellet Stove
NOTE: THESE INSTRUCTIONS MUST BE SAVED for future reference
PLEASE READ THIS ENTIRE MANUAL BEFORE INSTALLATION AND USE OF THIS PELLET
BURNING STOVE. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN PROPERTY
DAMAGE, BODILY INJURY OR EVEN DEATH.
IMPORTANT:
Always contact your local dealer/installer with questions before contacting the factory.
When you call have your serial number, purchase date, who installed the unit and a list of questions.
AMERICAN ENERGY SYSTEMS, INC. GRANTS NO WARRANTY, IMPLIED OR
STATED, FOR THE INSTALLATION OR MAINTENANCE OF THE STOVE AND
ASSUMES NO RESPONSIBILITY FOR ANY CONSEQUENTIAL DAMAGE(S).
AMERICAN ENERGY SYSTEMS, INC. -150 Michigan Street SE - HUTCHINSON, MINNESOTA 55350
Web
Site:
www.hearthdirect.com
9
When installing your
Magnum Corn/ Biomass / Wood Pellet
stove, particular attention needs to be made
in regards to fire protection. If the unit is not properly installed, a house fire may result. For your safety,
follow the installation and operation instructions provided, and if a question arises contact local building or
fire officials about restrictions and installation requirements in your area.
9
Read the operations and fuel section of this manual before plugging in your unit.
9
Always unplug the unit before attempting any service work.
9
Do not connect the unit to a chimney flue already serving another appliance.
9
When installing the chimney pipe to the unit, it is important to remember that the unit operates on a
negative pressure and the chimney on a positive pressure. All chimney connections, elbows and fittings
must be airtight.
(proper venting practices must be followed. Consult with a venting professional)
9
Ashes must be disposed of in a metal container with a tight fitting lid.
9
All minimum clearances to combustibles must be followed.
9
The
Magnum Corn/Biomass/Wood Pellet Stove
is tested for operation with wood pellets with an ash
content of no more than 2% and Corn with a moisture content from 10-14 percent.
It is recommended
that wood pellets with an ash content of 1% or less be used for efficient operation of this unit. Higher
ash content fuels will require additional maintenance and service. For use with wood pellets, cherry
pits, olive pits or other pelletized Biomass fuel. Corn with 11-12 percent moisture is ideal.
9
It is important to use fuel that is clean, dry and consistent.
Make sure that your supplier is giving you
the same fuel each time that you purchase. It is recommended that you purchase your entire heating season
supply of fuel at one time so that the fuel will be the same.
9
A voltage surge protector or ground fault outlet is required for this unit. The warranty will be
voided if surge protection is not installed before operating this unit.
9
A grounded outlet must be provided with proper polarity. A constant 115 volt (12volt on DC
models), 60 cycles must be provided for proper operation or the warranty of this appliance will be
forfeited.
9
Special attention needs to be taken to clean out the top heat exchangers of this unit on a regular
basis. The fly ash settles on the heat exchangers and must be cleaned off to keep the unit operating
properly. Check for plugging every two-four weeks or when needed.
9
If unit is not operated for extended periods of time (like summer) unplug the unit and disconnect the
battery to assure long life of electrical components.
OWNER’S MANUAL
Installation – Operation – Maintenance Instructions
