262150
36
Revision A
1034376
A
A
B
C
Figure 3.26: Taper Pin
5.
Install taper pin (A) as follows:
a.
Ensure tapered side of pin is facing gearbox shaft (B).
b.
Tap the pin into driveline yoke (C) until the pin end is
flush with the yoke.
1034378
A
B
C
Figure 3.27: Taper Pin
6.
Install washer (B) and nut (C). Tighten the nut to 150 Nm
(111 lbf·ft). When tightened, pin (A) will draw into the yoke
a few millimeters.
IMPORTANT:
After tightening the nut, the pin
MUST
be recessed into the
yoke 2
–
4 mm, otherwise driveline and gearbox damage
may occur.
ϭϬϯϴϬϭϯ
A
B
Figure 3.28: Driveline Cover
7.
Latch driveline cover (A) back onto the gearbox.
8.
Attach the driveline chain to plate (B) on the frame.
IMPORTANT:
Shorten the chain if necessary. Ensure the chain is short
enough to prevent wrapping around the driveline during
operation.
If putting the PTO driveline into storage position, proceed as follows:
NOTE:
The TM100 must be detached from the tractor before moving the storage bracket into the storage position.
Summary of Contents for TM100
