Introduction
2
2.1
OZONE WARNING
The ZETA
®
7215 Ultraviolet High Intensity Cure Chamber has been designed to operate safely
and reliably. However, if not used properly, it may become a potential hazard. All personnel
involved in the operation of the ZETA
®
7215 should be familiar with the operating safety
described in the Safety Considerations section of this manual. Ozone (O
3
) is a by-product of the
U.V. lamp. Ozone is a natural gas that is formed when Ultraviolet light from the sun is exposed
to the earth's atmosphere. Ozone has a pungent irritating odor. U.V. systems should not be
constantly operated in a confined room without proper ventilation. Exhausting the system to the
outside of the building will prevent ozone concentration in confined areas. Exhausting the ozone
is not dangerous to the atmosphere because the hot gas is unstable and breaks down to
oxygen usually before it leaves the ducting. Questions regarding installation, operation, or
safety should be addressed to Loctite Corporation Safety Health and Regulatory Affairs
Department in Rocky Hill, Connecticut, 1-800-LOCTITE (562-8483).
2.2
PURPOSE OF MANUAL
The purpose of this manual is to provide installation, operation and troubleshooting instructions
for the ZETA
®
7215 Ultraviolet High Intensity Cure Chamber. It is important the manual be
carefully read before any attempt to install or operate the equipment.
2.3
DESCRIPTION
The system is a bench top ultraviolet source designed for a wide range of Loctite
®
ultraviolet curing adhesives and coatings. The unit is suitable for laboratory use or
production requirements.
2.4
UNPACKING & INSPECTION
Visually inspect the shipping carton for physical damage. Damaged shipping cartons should be
reported to the carrier. Carefully open the shipping carton and remove the equipment, being
careful not to lose or damage any separately packed parts.
Check all parts against the packing list. Any damaged or missing parts should be reported to the
carrier and to your Loctite representative.
All packing materials and shipping carton should be saved in case the unit has to be returned at
some time in the future.
3
984135 Zeta 7215 & 7216 manl 8/3/00 3:23 PM Page 5
