BRAKES (CONTINUED)
SYMPTOM
PROBLEM: REMEDY
BRAKES WILL NOT APPLY
WHEN EMERGENCY LINE IS
DISCONNECTED
Initial air pressure too low:
allow air system to build up to
minimum 90 PSI and stabilize.
Defective relay valve:
repair or replace valve.
Air line leak:
locate leak and repair.
Brake chamber leak:
locate leak and repair or replace.
ABS WARNING LIGHT
STAYS ON
Refer to Rockwell WABCO ABS maintenance manual supplied
with semitrailer, for system function and use of blink code di-
agnostics
.
5-4 BRAKE DRUMS
SYMPTOM
PROBLEM: REMEDY
EXCESSIVE LOSS OF BRAKES OR
FADING
Overheated brake drums:
check for defective or misadjusted
brake linings, distorted or over-machined drums. Also check for op-
erating conditions or loads that create severe or excessive brake
applications.
BRAKES PULL TO EITHER SIDE
Drums of different diameters:
replace with drums of same di-
ameter.
Foreign matter in drums:
clean drums out.
ROUGH OR NOISY BRAKING
ACTION
Defective drums:
pull drums and inspect for any of the following;
Heat spotted drums, grease spotting, blue drums, scored drums,
excessive wear at rivet holes or edges, polished drums, out of
round drums, unbalanced drums, worn/damaged brake compo-
nents, foreign matter in drums. Correct situation or replace defec-
tive part(s).
VIBRATION IN RIDE
Defective drums or out-of-round:
replace drums.
Out-of-balance drums:
balance drums.
5-6
Summary of Contents for 825A
