PAGE
Pellet Grill
2
READ FIRST! RULES FOR PELLET GRILL SAFE OPERATION.
• WARNING!
THE GRILL IS FOR OUTDOOR USE ONLY!
• WARNING!
NEVER USE GASOLINE, GASOLINE-TYPE
FUEL, KEROSENE, CHARCOAL LIGHTER FLUID, OR
SIMILAR LIQUIDS TO START OR “FRESHEN UP” A FIRE
IN THIS APPLIANCE. KEEP ALL SUCH LIQUIDS AWAY
FROM THE APPLIANCE WHEN IN USE.
• DO NOT STORE FLAMMABLE LIQUIDS OR MATERIALS
ON THE BOTTOM SHELF OR SIDE SHELF.
• THE GRILL IS FOR ADULT USE ONLY.
• WARNING!
THIS GRILL GETS EXTREMELY HOT
DURING USE! USE EXTREME CAUTION AROUND THE
GRILL.
• USE CAUTION WHEN OPENING THE LID AS HOT
STEAM OR A FLARE UP COULD CAUSE BURNS.
• KEEP THE GRILL A MINIMUM OF 36 IN. AWAY FROM
BUILDINGS, STRUCTURES, ANY FLAMMABLE ITEMS
AND VEHICLES DURING USE.
• KEEP CHILDREN AND PETS AWAY WHILE THE GRILL IS
BEING USED.
• USE CAUTION AFTER THE FIRE HAS BEEN EXTIN-
GUISHED- SURFACES WILL REMAIN HOT FOR SOME
TIME.
• WARNING!
NEVER PUT YOUR FINGERS IN THE AUGER
CHANNEL FOR ANY REASON!
• THE HOPPER PELLET FUEL SCREEN MUST BE IN PLACE
DURING USE.
• NEVER USE THE GRILL UNDER COVERED PORCHES,
AWNINGS, COMBUSTIBLE CEILINGS, LOW HANGING
TREE BRANCHES, TRELLIS, OR OVERHANGS OF ANY
KIND.
• NEVER USE INSIDE ENCLOSED AREAS SUCH PATIOS,
GARAGES, ENCLOSED ROOMS, BUILDINGS OR TENTS.
• DO NOT USE IN WINDY CONDITIONS.
• DO NOT USE IN VERY WET OR RAINY CONDITIONS.
• KEEP THE LID CLOSED DURING USE. THIS PELLET
GRILL IS INTENDED TO BE USED WITH A CLOSED LID.
• NEVER USE THIS GRILL AS A HEATER.
• THIS GRILL IS NOT FOR COMMERCIAL USE.
• BEFORE STARTING, MAKE SURE THE GREASE BUCKET
IS IN PLACE.
• ALWAYS UNPLUG GRILL AFTER USING. WIND CORD
AROUND THE CORD WRAP SO IT IS OUT OF THE WAY.
• DURING USE, THE PLUG WIRING SHOULD BE SORTED
SO IT DOES NOT IMPOSE A TRIPPING HAZARD.
• ALWAYS USE THE GRILL ON A HARD, STABLE AND
LEVEL SURFACE.
• THIS GRILL OPERATES AUTOMATICALLY THROUGH THE
CONTROL PANEL. DO NOT MANUALLY FILL THE FIRE
POT OR OVER-FILL THE FIRE POT BY HAND . THIS WILL
CAUSE A DANGEROUS OVER-FIRING CONDITION.THE
SIDE SHELF CAN HOLD 15 LBS. SAFELY, DO NOT PUT
MORE THAN 15 LBS. ON THE SIDE SHELF.
• DO NOT LEAN OR PUSH DOWN ON THE SIDE SHELF.
• DO NOT MOVE THE GRILL WHILE IT IS BEING USED.
• DO NOT USE ACCESSORIES NOT SPECIFIED FOR USE
WITH THIS APPLIANCE.
• MAKE SURE THE FRONT WHEEL CASTERS ARE LOCKED
WHILE IN USE.
• DO NOT LEAVE UNATTENDED AT ANY TIME WHILE IN
USE.
• BEFORE EACH USE, MAKE SURE THE GRILL IS IN GOOD
WORKING CONDITION.
• DO NOT ALTER THE GRILL IN ANY WAY.
• DO NOT MODIFY OR HARDWIRE THE AUGER TO RUN
CONTINUOUSLY.
• DO NOT USE THE GRILL UNTIL IT IS COMPLETELY AS-
SEMBLED WITH ALL PARTS SECURELY TIGHTENED.
• THE GRILL MUST BE COMPLETELY COOLED OFF AND
MUST BE EXTINGUISHED BEFORE ANY COVER CAN BE
USED.
• MAINTAINING THE GRILL IS THE RESPONSIBILITY OF
THE OWNER OR USER . THE FIREBOWL, DRIP TRAY
AND DRIP TRAY TUBE MUST BE CLEANED OCCA-
SIONALLY TO REMOVE GREASE BUILDUP. FAILURE TO
CLEAN GREASE BUILDUP CAN CAUSE GREASE FIRES
WHICH ARE VERY DANGEROUS.
• WARNING! AFTER EVERY 20 HRS OF USE, THE FIRE
POT MUST BE CLEANED OUT TO REMOVE ANY ASH
BUILDUP. THIS IS REQUIRED MAINTENANCE.
• NEVER POUR WATER INTO THE FIREBOWL, FIRE POT
OR DRIP TRAY.
• IF A GREASE FIRE WERE TO OCCUR, BAKING SODA
CAN BE USED TO EXTINGUISH THE FIRE . USE EX-
TREME CAUTION NOT TO BURN YOURSELF.
• IF THE FIRE DOES NOT EXTINGUISH, REMOVE THE
FOOD IF POSSIBLE. KEEP THE LID CLOSED, CLOSE THE
CHIMNEY DAMPER AND PRESS THE POWER BUTTON
TO OFF.
• ONCE THE FIRE IS EXTINGUISHED, CLEAN THE GREASE
BUILDUP BEFORE COOKING IS RESUMED.
PLEASE READ THIS ENTIRE MANUAL BEFORE ASSEMBLING AND
USING THIS PELLET FUEL BURNING APPLIANCE.
FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN
PROPERTY DAMAGE, BODILY INJURY OR EVEN DEATH.
CONTACT LOCAL BUILDING OR FIRE OFFICIALS ABOUT RESTRICTIONS
AND INSTALLATION INSPECTION REQUIREMENTS IN YOUR AREA.
PLEASE SAVE THIS INSTRUCTION MANUAL FOR FUTURE REFERENCE.
Summary of Contents for 470430
