![background image](http://html1.mh-extra.com/html/jayco/jay-2016-series/jay-2016-series_user-manual_3475312147.webp)
SECTION 13 - EXTERIOR
JAYCO TOWABLE
TABLE OF CONTENTS
13-
4
When using any of the above products, please follow the cleaning product
manufacturer’s directions! If practical, use a wet/dry vacuum to remove all moisture
or excess cleaning product. Do not fold up tent while fabric is still wet or damp!
Most of the above items can be purchased at local hardware stores, and RV or Marine
dealers or supply stores.
F
RAME
Sand, pebbles, objects on the highway, climate (salt air exposure) or ice inhibiting
chemicals used during the winter months will damage the paint, inviting rust and other
deterioration. Periodically inspect the exterior exposed areas, clean and repaint the frame
members occasionally and whenever you notice rust or paint chipped away, to insure
protection.
E-Z
L
UBE OR
S
UPER
-L
UBE
A
XLE
(I
F
S
O
E
QUIPPED
)
The E-Z lube or Super-lube feature on your axles provides the ability for the bearings to be
periodically lubricated without removing the hubs from the axle. This feature consists of
axle spindles that have been specially drilled and fitted with grease zerks in their ends.
When grease is pumped into the zerk, it is channeled to the inner bearing and then flows
back to the outer bearing and eventually back out the grease cap hole. If you have further
questions, consult with your dealer.
NOTE
:
The convenient lubrication provisions of the E-Z lube or Super-lube feature
must not replace periodic inspection and maintenance of the bearings. Use a hand-operated
grease gun; improper use of a commercial grease gun may damage the seals.
E
XTERIOR
R
OOF
&
S
IDEWALL
V
ENTS
While you are cleaning the exterior roof assembly, also inspect the roof vents (including
sealants) for cracks and keep them clean. Inspect the refrigerator and holding tank vents
for blockages from bird nests, spider webs, leaves, etc. All exterior access doors and vents
need to be kept clean and free of obstructions (i.e., insect nests, mud daubers, etc.) while
the appliances are in use.
E
XTERIOR LADDER
(I
F
S
O
E
QUIPPED
)
Your recreation vehicle may be equipped with an optional roof ladder. The recreation
vehicle roof has decking under the rubber roof membrane to allow you to walk on the roof
(with caution) to do maintenance.
S
EALANTS
WARNING
If your recreation vehicle is equipped with a roof ladder, do not leave items attached
to it while traveling. The ladder weight capacity should not be exceeded (see ladder
capacity label). DO NOT exceed this weight limit. There should never be more than
one person on the ladder at the same time
CAUTION
Failure to properly maintain or reseal your recreation vehicle may result in serious
water damage to the roof and other parts of the recreation vehicle. This damage is not
covered by the
Towable Limited Warranty
.
Summary of Contents for jay 2016 series
