INSTALLATION PREPARATION
© 2013 Greenwood Clean Energy, Inc All Rights Reserved V1.9
Page 15
3. Locate the Furnace
The Frontier Series is certified for safety as an INDOOR APPLIANCE, so you can install it in a walk out
basement, shed, out-building or almost any location where the unit is sheltered from the weather and
insulated from intake air below 40°F (4.5°C).
DO NOT
install this furnace in a mobile home or trailer.
CAUTION:
As with any furnace operated indoors, you should install a carbon monoxide monitor and
take any other safety precautions to maintain safe oxygen levels in the room where the furnace is
installed.
NOTE:
Installation must be completed in accordance with National Fire Protection Association
(NFPA) installation standards No. 89M, 90B, 211, 70 (National Electrical Code) and Uniform
Mechanical Code 913, 6-4 in states where applicable.
The Frontier CX may be installed on a combustible floor provided that the bottom heat shield (shipped with
the boiler) is installed and the floor is protected from spillage of burning fuel particles by a noncombustible
surface (such as masonry, cement, or sheet metal) placed: (1) Underneath the furnace; (2) At least 16 inches
(406 mm) in front and 8 inches (203 mm) on either side of the fuel-loading and ash-removal door; and (3)
Underneath the chimney connector and extending at least 2 inches (50 mm) on either side of the chimney
connector.
When deciding where to place the unit, consider the location of your chimney, access to electricity, and the
convenience of retrieving and loading wood.
Minimum Installation Clearances
Greenwood Frontier Series boilers
are tested to Underwriters
Laboratories (UL) and Canadian
Standards Association (CSA)
standards of safety for indoor
appliances. As a result, you can
install your furnace with a
minimum separation between the
furnace, walls and ceilings. The
following table and illustrations
show the minimum clearances to
combustible materials.
Furnace Face
Minimum Clearance
Notes
A
Ceiling to horizontal flue or
chimney
18 inches (45.7 cm)
B
Ceiling to appliance top
18 inches (45.7 cm)
C Bottom of channels to floor
0 inches (0 cm)
Use non-combustible surface
and install heat shield if
installed on combustible floor.
D Rear wall to appliance
36 inches (91.4 cm)
E
Sidewall to appliance
6 inches (30.5 cm)
Recommend right side has at
least 30” clearance to allow for
convenient maintenance.
F
Front wall to appliance
36 inches (91.4 cm)
Summary of Contents for Frontier CX
