Genius RAINBOW 524 C, Manual For The Installer

Page: 9 / 56

RAINBOW 524 C- RAINBOW 724 C
ENGLISH
Guide for the installer
Page 7
Thank you for choosing our product. GENIUS is sure you will get
the performances you expect to satisfy your requirements. All our
products are the result of a many years’ experience in the field of
the automated systems, strengthened by being part of a world
leading group in this sector.
In the middle of the manual you will find a detachable
booklet containing all the images for the installation.
The automated systems of the RAINBOW family are electro-
mechanical barriers which have been designed and built to control
vehicle accesses.
The control unit is located on the upper part of the automated
system and can be rotated to facilitate wiring and setting
operations. Suitable facilities for the photocells (Orion) and the key
selector (Quick) are present on the housing. Both on the housing
and on the rods you can install luminous strips, replacing thus the
traditional flashing lamp.
Thanks to the various types of rods available, these can be used
in very different types of accesses, from a minimum of 3 meters up
to a maximum of 7 meters.
A handy release device, protected by customised key, enables you
to move the rod by hand in the event of a power cut.
Thanks to the use of 24V motors and of the encoder (standard
supplied), all automated systems of the RAINBOW family are able
to guarantee very high safety levels.
IMPORTANT WARNINGS FOR THE INSTALLER
Carefully read the whole manual before beginning to install the
operator.
Store the manual for future reference.
The correct operation and the declared technical specifications
are only valid if the instructions given in this manual are strictly
observed and only GENIUS accessories as well as safety device
are used.
To guarantee an adequate level of safety of the automated
system, the use of a control unit with an adjustable electronic
clutch is necessary due to the lack of a mechanical clutch .
The automated system was designed and built to control vehicle
access. Avoid any other use.
The operator cannot be used to move safety exits or gates installed
on emergency routes (escape routes).
Do not transit when the rod is moving.
Anything not expressly specified in this manual is not permitted.
1. DESCRIPTION
With reference to figure 1:
Pos. Description
a
Upright
b
Panel
c
Foundation plate (sold as a separate part)
d
Cover
e
Control unit enclosure
f
Rod fitting cover
g
Rod (sold as a separate part according to installation
requirements)
h
Balance spring (sold as a separate part, number and type
according to rod type and to fitted accessories)
i
Gearmotor
j
Encoder
k
Closing / opening travel limits
l
Safety travel limit
m
Red edge (cover for optional luminous strip)
n
Release device
o
Compartment for buffer batteries (not supplied)
•
•
•
•
•
•
•
•
1.1 TECHNICAL SPECIFICATIONS
RAINBOW Model 524 C 724 C
Power supply voltage 230Vac 50Hz / 115Vac 60Hz
Motor supply voltage (Vdc) 24
Max. power at thrust (W) 280 480
Motor rated power (W) 160 220
Max. torque at 24Vdc (Nm) 140 370
Operating rated torque (Nm) 75 140
Opening / closing nominal time
(sec)
a
4 to 8 7 to 11 to 11 11
Rod max. length (m)
b
5 7
Type and use frequency at 20°C Semi-intensive
Daily max. cycles (cycles) 1000 500
Operating ambient temperature
(°C)
-20 +55
Noise (dBA) <70
Protection class IP 54
Operator weight (Kg) 66 72
Dimensions See fig. 2 See fig. 3 3
a
Time according to the type of deceleration being set.
b
Length referred to the passage width, rod length +400mm
approx
1.1.1. p
roduct
l
ife
The tables below indicate the product life, expressed in number
of cycles, according to the type of selected rod and to the
accessories fitted to it:
RAINBOW 524 C
Rod and accessory Life (No. of cycles)
3 meters 1.500.000
4 meters 1.300.000
5 meters 1.100.000
3 meters with foot 1.300.000
4 meters with foot 1.100.000
5 meters with foot 800.000
3 meters with 2 m skirt 1.300.000
4 meters with 3 m skirt 1.100.000
5 meters with 4 m skirt 800.000
RAINBOW 724 C
Rod and accessory Life (No. of cycles)
4 meters 1.300.000
5 meters 1.100.000
6 meters 850.000
7 meters 500.000
4 meters with foot 1.100.000
5 meters with foot 850.000
6.5 meters with foot 500.000
4 meters with 2 m skirt 1.100.000
5 meters with 3.5 m skirt 850.000
6.5 meters with 5 m skirt 500.000
The product life has been calculated at a temperature of 20°C
on correctly installed operators, according to the specifica-
tions indicated in the instructions.