LUBRICATION & MAINTENANCE
LUBRICATION & MAINTENANCE
Boom Sprayer 9500 / 9600
Page 103
Cleaning
Filters
The fluid in the sprayer is continually being
filtered through a screen filter in the boom
control, agitation, and boom feed lines. The
sprayer must have clean water to prevent
clogging of the screens and check valves
when in use. These screens must be cleaned
daily or more often as required. To clean,
follow this procedure:
1.
At the start of each day before the water
and chemicals are added, the screens
should be checked and cleaned.
2.
If there is water or solution in the sprayer,
close the sump valve to isolate the
screens.
3.
Loosen the filter bodies by hand. Do not
use a wrench as this could damage the
filter body.
4.
Remove the screens and inspect them
for dirt.
5.
Clean them using clean water.
6.
Inspect for holes or tears. If there is
damage, replace it.
7.
Install the screens and body to the filter
heads and tighten by hand. Do not use a
wrench as this might damage the body.
Do not over tighten and crack the head.
8.
Open the ball valves to allow the solution
to circulate.
9.
Drain all screens before storage to avoid
freezing.
Figure 50: Boom feed line filter
Figure 51: Typical boom line filter
Tank
WARNING: Do not enter the tank at
any time.
Daily
At the end of the working day, clean the
system using this procedure:
1.
After the chemical solution has been
completely sprayed out through the
booms, add 20 gallons (75 liters)
clear water to the tank.
2.
Run the agitation pump for 5 minutes.
3.
Spray the rinse lightly over previously
sprayed crop.
4.
Repeat Steps 1 - 3 with 30 gallons of
water.
5.
Rinse the system again with clean
water.
6.
Clean the screen and nozzles.
7.
Drain the tank and let it dry.
To Remove Salt and Amines Formations
or Change Chemicals
Perform this cleaning cycle when changing
chemicals and/or annually.
1.
Follow the procedure for
daily
cleaning
.
2.
Remove all screens and nozzles and
wash them separately.
3.
Add 50 gallons (200 liters) of clean
water to the tank.
Summary of Contents for 9500
