Everglades 2012 275 CC, Owner'S Manual

Page: 144 / 148

144
Troubleshooting Guide
PRObLEM CAUSE AND SOLUTION
ENGINE PROBLEMS
An engine is running too hot.
• The engine raw water pick up strainer is clogged with marine
growth. Clean pick up.
• The engine raw water pump impeller is worn or damaged.
Repair the pump.
• The engine thermostat is faulty and needs to be replaced.
An engine alternator is not charging properly. • The battery cable is loose or corroded. Clean and tighten
battery cables.
• The alternator is not charging and must be replaced.
• The battery is defective. Replace the battery.
An engine suddenly will not operate over 2000 RPM.
• The engine emergency system has been activated. The on
board computer has sensed a problem and has limited the
RPM to protect the engine. Find & correct the problem.
• The tachometer is bad and needs to be replaced.
• The oil tank on 2-cycle engines is low on oil. Fill the engine
oil tank. Refer to the engine owner’s manual.
• A throttle control is not responding properly. Have the
throttle setting checked by a qua lified technician.
An engine is loosing RPM. The boat is not overloaded and
the hull bottom and running gear are clean and in good
condition.
• The engine may be having a problem with a sticky Anti-
siphon valve, located in the fuel line near the fuel tank, that
is restricting the fuel flow. Remove & clean or replace the
Anti-siphon valve.
• The remote gasoline fuel filter could be dirty. Inspect and
replace the fuel fil ter.
• The primary fuel filter on the engine may be dirty. Inspect
and replace the fuel filter.
• The electronic engine control system on the engine is mal-
functioning. Repair the engine control system.
• The fuel injection system on the engine is malfunctioning .
Repair the fuel injection system.