22
CA280 M280EN1
3
2
1
2
1
EVERY 500 HOURS OF OPERATION (Every three months)
Fig. 31 Engine
1. Screw
2. Glass bowl
3. Strainer
Fuel pre-filter
– Cleaning
Place the roller on a level base. The engine
must be switched off and the parking brake
applied for all checking and adjustments
on the roller unless stated otherwise.
Loosen the screw (1) and remove the bowl (2).
Take out the strainer (3) and clean in a non-flammable
fluid. Replace the filter as required. Fit the strainer and
bowl.
Start the engine and check that the pre-filter does not
leak.
Make sure there is adequate ventilation
(extraction) if the diesel engine is run in-
doors. Risk of carbon monoxide poisoning.
Fig. 32 Left side of engine
1. Drain plug
2. Oil filter
Diesel engine
– Oil and filter change
Place the roller on a level surface. Switch
off the engine and apply the parking brake/
Reserve brake.
The oil drain plug (1) is most easily accessible from
underneath the engine. Drain off the oil while the engine
is warm. Place a receptacle that holds at least 15
liters(16 qts) under the drain plug.
Observe caution when draining hot oil.
Protect your hands.
Fill oil according to the engine manual. Replace the
engine oil filter (2) at the same time. See also engine
instruction manual.
Dispose of the drained oil and filter in an
approved manner.
Summary of Contents for CA280
Page 2: ...19 ILF015WO1 ...
Page 35: ......
