3-7
Inspecitions/Adjustments
Brake Fluid
Front brake fluid
●
Remove the screw rivet and take the front brake
fluid maintenance lid off.
●
Check the oil level inside the front brake reservoir.
If the oil is near the lower limit line, remove the
reservoir diaphragm and fill DOT 3 and DOT 4
brake fluid to the top limit line.
●
If the brake fluid reaches the lower limit line,
check the entire brake system for leaks.
Brake Pad
Front brake pad replacement
●
Check the front brake pads for wear.
●
If the red mark on the pad reaches the brake disk,
replace the pads.
Rear brake pad replacement
●
Replace in the some method as that of front brake
pad replacement.
NOTE
Rear brake fluid
●
Replenish in the same method as that of front
brake fluid replenishment.
Brake System
●
Check the front brake hose and the rear brake
hose for cracks or damage. If any leaks are
found, replace immediately.
●
Check the front brake rod and the rear brake rod
for looseness or damage, and replace it if
necessary.
•
Replace the brake pads in sets.
Front master cylinder
Front
Red mark
Front brake
hose
Front brake caliper
Rear brake caliper
Red mark
Rear master cylinder
Rear
Summary of Contents for NS125DLX
