CleanSpace CS302, User Instructions

Page: 33 / 90

33
Figure 29 – Charging Port

Charging is complete when the blower shows three (3) green solid lights. If the third green LED is
flashing rapidly, charging is 95% complete.
 When the respirator is fully charged, disconnect the charger cable from the blower charging port.
 Note: The battery can only be charged at temperatures between 32°F and 95°F (0°C and 35°C). Outside
this temperature range no charging will occur.
LOW BATTERY ALARM
Your respirator has a low battery alarm, which is triggered when the battery has approximately 5 minutes life
remaining (3 beeps, repeated every second). You cannot mute the low battery alarm except by connecting the
respirator to its charger or by stopping the motor (doff the respirator and either press the Power Button once or allow
the respirator to detect that there is no breathing and stop).
When the battery voltage becomes extremely low, the motor will stop.
WARNING
If the battery alarm sounds (3 beeps, repeated every second), leave the contaminated area
immediately and re-charge the battery.
Operating the respirator after the low battery alarm has sounded can cause the flow to fall below
the manufacturer’s minimum designed flow, which may result in overexposure to contaminants and
lead to sickness.
GENERAL BATTERY INFORMATION
Your respirator has an internal lithium ion (Li-ion) polymer battery. Lithium ion (Li-ion) batteries have the highest
energy density of all battery types and are widely used today in portable electronic devices across many different
industries. The commonly available Li-ion polymer batteries are similar to Li-ion batteries, except they are packaged
in a soft polymer film as opposed to the metal case commonly used for Li-ion cells. The soft packaging allows the
cells to expand slightly under extreme heat, making them safer in fault conditions. CleanSpace respirators use
quality Li-ion polymer batteries and are designed to be viable over a minimum of 500 complete charge and discharge
cycles while still maintaining at least 70% of their specified full capacity.
RESPIRATOR STORAGE
To maintain the integrity of the internal battery, the respirator must be stored under the following conditions when not
being used:
Long term storage (> 30 days)
30% - 50% RH, 65°F to 82°F (18°C to 28°C)
Short term storage (< 30 days) 30% - 50% RH, 14°F to 95°F (-10°C to 35°C)
The following precautions must be followed during use:
Turn the respirator over and check that one of the green LEDs on the keypad is flashing . If none of the
LEDs is flashing, the unit is not charging. Check that the charger is plugged into the wall socket and the
charger cable is plugged securely into the socket on the underside of the respirator. If the respirator is still not
charging, contact CleanSpace Customer Service on +612 8436 4000.
Do not charge the battery in electro-magnetically noisy environments, such as near welding machines.