Page 4
Important Safety Information
Always read this manual before fitting or operating the machine
–
whenever any doubt exists contact your
dealer or the Chapman Machinery Service Department for advice and assistance.
DEFINITIONS
The following definitions apply throughout this manual:
WARNING -
An operating procedure, technique etc., which can result in personal injury or loss of life if
not observed carefully.
CAUTION -
An operating procedure, technique etc., which can result in damage to either machine or
equipment if not observed carefully.
NOTE
- An operating procedure, technique etc, which is considered essential to emphasis.
LEFT & RIGHT HAND
- This term is applicable to the machine when attached to the towing vehicle and is
viewed from the rear
–
this also applies to tractor references.
Safety Information
•
Do not operate this equipment unless you have studied this manual in full
•
Only use this machine for its designated task - improper use is both highly dangerous and damaging to
machine components
•
Both operators & maintenance fitters should be familiar with the machine and fully aware of dangers
surrounding improper use or incorrect repairs
•
Before starting, carry out a visual check on both machine & towing vehicle as regards functionality, road
safety & accident prevention rules
•
Even when using the machine correctly, foreign objects such as stones may be thrown a considerable
distance. It is imperative that nobody stand within the danger area. If working near roads, buildings children
or animals provision must be made for containment of ejected material and sufficient warning signs / notices
placed around the working area
•
The condition of flails and of machine guards must be checked before beginning the
day’s
work. Worn or
damaged flails must be replaced before you use the machine. Flails must be replaced in pairs to ensure rotor
balance is maintained.
•
During checks or repairs, ensure the machine cannot be started by other persons by mistake
•
Never wear loose clothing which could get caught in rotating equipment
•
Never carry passengers on the towing vehicle
•
Never approach the machine until the rotor has stopped rotating
•
Do not stand near the machine when operating
•
Damaged or missing safety decals must be replaced immediately
•
Before leaving the machine unattended, remove the starting key (if applicable)
•
ENSURE emergency stop switch is SECURELY attached to the towing vehicle and within reach of the operator
at all times
