Case SV208D, Service Manual

Page: 10 / 31

INTRODUCTION
Personal safety
General safety rules
Use caution when you operate the machine on slopes. Raised equipment, full tanks and other loads will change the
center of gravity of the machine. The machine can tip or roll over when near ditches and embankments or uneven
surfaces.
Never permit anyone other than the operator to ride on the machine.
Never operate the machine under the influence of alcohol or drugs, or while you are otherwise impaired.
When digging or using ground-engaging attachments, be aware of buried cables. Contact local utilities to determine
the locations of services.
Pay attention to overhead power lines and hanging obstacles. High voltage lines may require significant clearance
for safety.
Hydraulic oil or diesel fuel leaking under pressure can penetrate the skin, causing serious injury or infection.
• DO NOT use your hand to check for leaks. Use a piece of cardboard or paper.
• Stop the engine, remove the key, and relieve the pressure before you connect or disconnect fluid lines.
• Make sure that all components are in good condition. Tighten all connections before you start the engine or pres-
surize the system.
• If hydraulic fluid or diesel fuel penetrates the skin, seek medical attention immediately.
• Continuous long term contact with hydraulic fluid may cause skin cancer. Avoid long term contact and wash the
skin promptly with soap and water.
Keep clear of moving parts. Loose clothing, jewelry, watches, long hair, and other loose or hanging items can become
entangled in moving parts.
Wear protective equipment when appropriate.
DO NOT attempt to remove material from any part of the machine while it is being operated or while components are
in motion.
Make sure that all guards and shields are in good condition and properly installed before you operate the machine.
Never operate the machine with shields removed. Always close access doors or panels before you operate the ma-
chine.
Dirty or slippery steps, ladders, walkways, and platforms can cause falls. Make sure these surfaces remain clean and
clear of debris.
A person or pet within the operating area of a machine can be struck or crushed by the machine or its equipment. DO
NOT allow anyone to enter the work area.
Raised equipment and/or loads can fall unexpectedly and crush persons underneath. Never allow anyone to enter
the area underneath raised equipment during operation.
Never operate the engine in enclosed spaces as harmful exhaust gases may build up.
Before you start the machine, be sure that all controls are in neutral or park lock position.
Start the engine only from the operator’s seat. If you bypass the safety start switch, the engine can start with the
transmission in gear. Do not connect or short across terminals on the starter solenoid. Attach jumper cables as
described in the manual. Starting in gear may cause death or serious injury.
Always keep windows, mirrors, all lighting, and Slow-Moving Vehicle (SMV) emblem clean to provide the best possible
visibility while you operate the machine.
Operate controls only when seated in the operator’s seat, except for those controls expressly intended for use from
other locations.
48150518 26/02/2018
5
Find manuals at https://best-manuals.com