Outdoor LP Gas Barbecue Grill
Model No. GBT1508BB
2
W
This grill is for outdoor use only, and should not be used in a building,
garage or any other enclosed area.
W
Do NOT operate, light or use this appliance within ten feet (3.05 m) of
walls, structures or buildings.
W
For residential use only. This grill is NOT for commercial use.
W
This grill is not intended for and should never be used as a heater. TOXIC
fumes can accumulate and cause asphyxiation.
W
This is NOT a tabletop grill. Therefore, do NOT operate this grill on any
type of tabletop surface.
W
This grill is safety certified for use in the United States and/or Canada
only. Do NOT modify for use in any other location. Modification will
result in a safety hazard and will void your warranty.
W
This grill is for use with liquid propane (LP) gas only. The conversion to
or attempted use of natural gas in this LP gas grill is dangerous, may
cause bodily harm and will void your warranty.
W
Do NOT over heat this grill as this will damage the grill and could cause
a fire or an explosion which can cause death, serious bodily injury or
damage to property.
W
LP gas characteristics:
a. LP gas is flammable and hazardous if handled improperly. Become
aware of the characteristics before using any LP gas product.
b. LP gas is explosive under pressure, heavier than air, and settles and
pools in low areas.
c. LP gas in its natural state has no odor. For your safety, an odorant is
added that smells like rotten cabbage.
d. Contact with LP gas can cause freeze burns to skin.
W
Apartment dwellers: Check with management to learn the requirements
and fire codes for using a LP gas grill in your apartment complex.
If allowed, use outside on the ground floor with a ten foot (3.05 m)
clearance from any structure. Do NOT use on or under balconies.
W
LP gas cylinder needed to operate. Only cylinders marked “propane”
may be used.
W
The LP gas cylinder must be constructed and marked in accordance
with the
Specifications for LP-gas Cylinders
of the U.S. Department
of Transportation (D.O.T.),
Cylinders, Spheres and Tubes for the
Transportation of Dangerous Goods;
or the National Standard of Canada,
CAN/CSA-B339.
W
LP gas cylinder must be arranged for vapor withdrawal.
W
Dented or rusted LP gas cylinders may be hazardous and should be
checked by your LP gas supplier prior to use.
W
The LP gas cylinder should not be dropped or handled roughly.
W
LP gas cylinders must be stored outdoors out of the reach of children
and must not be stored in a building, garage or any other enclosed area.
Your cylinder must never be stored where temperatures can reach over
125°F.
W
Do NOT insert any tool or foreign object into the valve outlet or safety
relief valve. You may damage the valve and cause a leak. Leaking
propane may result in an explosion, fire, severe personal injury or death.
W
Do NOT block holes in sides, bottom or back of grill.
W
Never keep an LP gas cylinder in a hot car or trunk. Heat will cause the
gas pressure to increase, which may open the relief valve and allow gas
to escape.
W
Do NOT store a spare LP gas tank under or within 25 feet (7.62 m) of this
appliance.
W
Never attempt to attach this grill to the self-contained LP gas system of
a camper trailer, motor home or house.
W
The use of alcohol, prescription or non-prescription drugs may impair
the consumer’s ability to properly assemble or safely operate the
appliance.
W
Strong odors, colds, sinus congestion, etc. may prevent the detection of
propane. Use caution and common sense when testing for leaks.
W
NEVER use lighter fluid, lava rocks, gasoline, kerosene or alcohol with
this product.
W
NEVER use charcoal when using as a LP gas grill.
W
Your grill has been checked at all factory connections for leaks.
Recheck all connections as described in the “Operating Instructions”
section of the manual, as shipping can loosen connections.
W
Check for leaks even if your unit was assembled for you by someone
else.
W
Do NOT operate if a gas leak is present. Gas leaks may cause a fire or
explosion.
W
You must follow all instructions in the “Checking for Leaks” section
before operating. To prevent a fire or explosion hazard when testing for
a leak:
a. Always perform a leak test before lighting the grill and each time
the cylinder is connected for use.
b. No smoking. Do NOT use or permit sources of ignition in the area
while conducting a leak test.
c. Conduct the leak test outdoors in a well-ventilated area.
d. Do NOT use matches, lighters, or a flame to check for leaks.
e. The use of alcohol, prescription or non-prescription drugs may
impair the consumer’s ability to properly assemble or safely operate
the appliance.
f. Strong odors, colds, sinus congestion, etc. may prevent the
detection of propane. Use caution and common sense when testing
for leaks.
g. Do NOT use grill until any and all leaks are corrected. If you are
unable to stop a leak, disconnect the LP gas supply. Call a gas
appliance serviceman or your local LP gas supplier.
W
Do NOT store or use gasoline or other flammable liquids or vapors
within 25 feet (7.62 m) of this appliance.
W
Do NOT use in an explosive atmosphere. Keep grill area clear and free
from combustible materials, gasoline and other flammable vapors and
liquids.
W
Minimum clearance from sides and back of unit to combustible
construction is 36 inches (91.4 cm). Do NOT use this appliance under
any type of overhang or roof.
W
It is essential to keep the grill’s regulator and valve assembly, burners
and circulating air passages clean.
W
Inspect grill before each use.
W
Do NOT alter grill in any manner. Any alteration will void your warranty.
W
Do NOT use the grill unless it is COMPLETELY assembled and all parts
are securely fastened and tightened.
W
This grill should be thoroughly cleaned and inspected on a regular
basis.
W
Clean and inspect the hose before each use of the appliance. If there
is evidence of abrasion, wear, cuts or leaks, the hose must be replaced
prior to operation.
W
Use only the pressure regulator provided. Use only the replacement
pressure regulator specified by Blue Rhino Global Sourcing, Inc.
W
Do NOT attempt to repair or alter the pressure regulator for any
assumed defect. Any modification to this assembly will void your
warranty and create the risk of a gas leak and fire. Use only authorized
replacement parts supplied by manufacturer.
W
Use only Blue Rhino Global Sourcing, Inc. factory-authorized parts. The
use of any part that is not factory-authorized can be dangerous and will
void your warranty.
W
Do NOT operate this appliance without reading “Operating Instructions”
in this manual.
W
Do NOT touch metal parts of grill until they have completely cooled
to avoid burns, unless you are wearing protective gear (pot holders,
gloves, BBQ mitts, etc.).
W
Do NOT install or use in or on boats or recreational vehicles (RV).
W
Do NOT use grill in a vehicle trunk, station wagon, mini-van or sport
utility vehicle (SUV).
W
DANGER: Failure to follow the dangers, warnings and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion
causing damage to property.
W
WARNINGS:
Important Safeguards - LP Gas
