PAGE 4
SECTION 1:
BASIC INFORMATION
Congratulations on the purchase of your new Bad Boy Mower! The purpose of this manual is to assist
operators in maintaining and operating their machine. The information and instructions in this manual can help
you attain years of performance from your new Bad Boy. Also, check out our website to learn more about the
Bad Boy family.
1.1
All Bad Boy engines use 10W-30 engine oil. For maximum protection, Bad Boy synthetic blend engine
oil is recommended.
1.2
All Bad Boy hydraulic systems use 20W-50 engine oil (Conventional or Synthetic). Bad Boy Hydrostatic
oil is recommended.
1.3
All Bad Boy Mowers use hi-temp multi-purpose grease. NLGI No. 2 for the grease fittings.
1.4
WALK-BEHIND models have 12 psi in both front and rear tires.
1.5
Most Kawasaki engines hold approximately two (2) quarts of motor oil. Be careful not to over fill engine
oil. Refer to engine’s service manual.
WARRANTY REGISTRATION
The Warranty Registration form must be completed within 30 days to validate your warranty. As the new
equipment owner, you are expected to see that the form is completed and forwarded to Bad Boy Inc. at time of
delivery. Warranty is nontransferable
. Warranty registration should be completed by the selling
dealership using the on-line registration site.
MODEL/SERIAL NUMBER
Your WALK-BEHIND model serial numbers are found on the SIN plate on the inside of the control upright.
These numbers can assist you in the ordering of new parts when replacements become necessary.
PARTS/SERVICE
Bad Boy recommends using Bad Boy replacement parts on your mower. Replacement parts are available
through your local Bad Boy Mowers Dealer. Remember to always provide the following information when
ordering parts:
1.
Correct part number
2.
Correct serial number
All warranty repair and service must be handled through your authorized Bad Boy Mowers Dealer. To locate
the nearest dealer, go to our website and click on Locate a Dealer.
EVAPORATIVE EMISSION CONTROL WARRANTY STATEMENT
Federal Evaporative Emission Control Warranty: Your Warranty Rights and Obligations
The Environmental Protection Agency (EPA), and Bad Boy Inc. are pleased to explain the evaporative emission
control system's warranty on your 2020 equipment. New equipment that uses spark ignition engines for off-
road use must meet stringent anti-smog standards. the evaporative emission control system on your
equipment is designed, built, and equipped so it conforms at the time of sale to the ultimate purchaser with the
requirements of 40 CFR 1060. The evaporative emission control system is free from defects in materials and
workmanship that may keep it from meeting said requirements. Bad Boy Inc. must warrant the evaporative
mission control system on your equipment for two years provided there has been no abuse, neglect, or
improper maintenance. If an evaporative emission control system component does fail in a manner that would
cause the equipment to no longer meet the requirements of 40 CFR 1060 within the first two years Bad Boy Inc.
will replace the defective component. Your evaporative emission control system may include parts such as fuel
tanks, fuel lines, carbon canisters, fuel caps, valves, vapor hoses, clamps, or connector.
