Cleaning Device d-800 Page 8
equipment and facility engineering
3.4 Hazards from pneumatic energy
Only specialists with special knowledge and experience may work on pneumatic equipment. When
working on pneumatic aggregates or elements, these must be made pressureless beforehand in
order to prevent injury!
Prevent disconnected not pressurized compressed air supply lines from restarting. If the systems
leaks, disconnect it from air supply and then tighten the screwed connections.
3.5 Excitation for operating instructions
Operating instructions are regulations that a company creates for safe operation. These are binding
instructions issued by the entrepreneur within the framework of his management right. The
employees are obligated to follow these instructions.
The general obligation of the entrepreneur to create and publish operating instructions is laid down
in the Occupational Safety and Health Ordinance (BetrSichV), the water resources law (WHG) and,
where applicable, the Ordinance on Hazardous Substances (GefStoffV). The present operating
instructions are therefore to be complemented by national regulations on accident prevention (UVV)
and environmental protection.
Give information to the employee about:
• the dangers involving the handling of contaminated parts and the solvents used, the necessary
protective measures and behavior, including instructions in case of danger and first aid.
• Type and scope of periodic inspection for safe working condition of the device
• Environmental Protection
• Safe handling of the pneumatic system
• By means of instructions and controls, the user has to ensure cleanliness and clarity at the
workplace of the device.
• The responsibility for operation must be clearly regulated by the user and must be complied by all
persons, so that no unclear competences occur under the safety aspect.
• The operator has to undertake to operate the cleaning device only in perfect condition and to
immediately notify its supervisor of any changes that affect safety and environmental protection.
• Observe all warnings and warning signs.
• The user has to ensure that no unauthorized persons are at the cleaning device.
It is prohibited to open the pump case in B-TEC cleaning devices!
The manufacturer is not liable for any damage and/or secondary/following damage caused
by opening the pump case on purpose or negligent opening.
If you got any problems with your pump device, please contact your distributor or the B-
TEC support.
