66
1. Secure the ATV on a support stand
to elevate the front wheels.
2. Remove both front wheels.
3. Inspect the four tie rod boots for
cracks, tears, or perforations.
4. Check the tie rod end free-play by
grasping the tie rod near the end
and attempting to move it up and
down.
5. If boot damage is present or tie rod
end free-play seems excessive,
contact an authorized Arctic Cat
ATV dealer for service.
BATTERY
The battery is located under the seat.
After being in service, batteries require
regular cleaning and recharging in
order to deliver peak performance and
maximum service life. The following
procedure is recommended for clean-
ing and maintaining a sealed battery.
Always read and follow instructions
provided with battery chargers and bat-
tery products.
NOTE: Battery maintenance can
be performed by the ATV owner if
qualified to do so. If the owner
does not feel qualified, take the
ATV to an authorized Arctic Cat
ATV dealer for this service. This
service is at the discretion and
expense of the ATV owner.
1. Remove the battery hold-down;
then disconnect the battery cables
(negative cable first).
2. Remove the battery from the bat-
tery compartment; then thoroughly
wash the battery and battery com-
partment with soap and water.
NOTE: If battery posts, cable
ends, or the battery case has a
build-up of white/green powder
residue, apply water and baking
soda to neutralize acid; then flush
off with warm soapy water.
3. Using a wire brush, clean the bat-
tery posts and cable ends removing
all corrosive buildup. Replace
damaged cables or cable ends.
4. Using a multimeter, test the battery
voltage. The meter must read at
least 12.5 DC Volts for a fully
charged battery.
NOTE: At this point, if the meter
reads as specified, the battery may
be returned to service (see step 8).
5. If the meter reads less than speci-
fied voltage, charge the battery
using the following guidelines.
A. When using an automatic bat-
tery charger, always follow the
charger manufacturer’s instruc-
tions.
B. When using a constant-current
battery charger, use the follow-
ing Battery Charging Chart.
! WARNING
Anytime service is performed on a
battery, the following must be
observed: keep sparks, open flame,
cigarettes, or any other flame away.
Always wear safety glasses. Pro-
tect skin and clothing when han-
dling a battery. When servicing
battery in enclosed space, keep the
area well-ventilated.
CAUTION
Do not remove seal strip.
! WARNING
Battery acid is harmful if it contacts
eyes, skin, or clothing. Care must be
taken whenever handling a battery.
CAUTION
Never exceed the standard charging
rate.
