Arctic Cat ATV 2010, Operator'S Manual

Page: 49 / 72

47
GENE
RA
L
MAINTEN
ANC
E
3. Inspect the four tie rod
boots for cracks, tears, or
perforations.
4. Check the tie rod end free-
play by grasping the tie
rod near the end and
attempting to move it up
and down.
5. If boot damage is present or tie rod end free-play seems
excessive, contact an authorized Arctic Cat ATV dealer for
service.
BATTERY
The battery is located under the seat.
After being in service, batteries require regular cleaning and
recharging in order to deliver peak performance and maximum
service life. The following procedure is recommended for clean-
ing and maintaining a sealed battery. Always read and follow
instructions provided with battery chargers and battery products.

NOTE: Battery maintenance can be performed by the
ATV owner if qualified to do so. If the owner does not feel
qualified, take the ATV to an authorized Arctic Cat ATV
dealer for this service. This service is at the discretion and
expense of the ATV owner.
1. Remove the battery hold-down; then disconnect the battery
cables (negative cable first).
2. Remove the battery from the battery compartment; then thor-
oughly wash the battery and battery compartment with soap
and water.

NOTE: If battery posts, cable ends, or the battery case
has a build-up of white/green powder residue, apply water
and baking soda to neutralize acid; then flush off with
warm soapy water.
3. Using a wire brush, clean the battery posts and cable ends
removing all corrosive buildup. Replace damaged cables or
cable ends.
4. Using a multimeter, test the battery voltage. The meter must
read at least 12.5 DC Volts for a fully charged battery.

NOTE: At this point if the meter reads as specified, the
battery may be returned to service (see step 8).
5. If the meter reads less than specified voltage, charge the bat-
tery using the following guidelines.
A. When using an automatic battery charger, always follow
the charger manufacturer’s instructions.
! WARNING
Anytime service is performed on a battery, the following
must be observed: keep sparks, open flame, cigarettes, or
any other flame away. Always wear safety glasses. Protect
skin and clothing when handling a battery. When servicing
battery in enclosed space, keep the area well-ventilated.
MD0041
CAUTION
Do not remove seal strip.
! WARNING
Battery acid is harmful if it contacts eyes, skin, or clothing.
Care must be taken whenever handling a battery.