Section #: Title
4
©Aqua-Hot®
600D and 675D Use and Care Guide
Safety and Precautions
The Aqua-Hot Heating System
Read and understand all instructions before installing this
unit.
•
Read this owner’s manual before installing or using the
Aqua-Hot system to reduce the risk of injury to persons or
damage to equipment.
•
The product identity label contains specifications of the
unit, to what standard it has been tested, and important
safety notices.
•
The Aqua-Hot must be installed in a compartment that is
closed off from living quarters and accessible only from
the outdoors.
•
Propylene glycol based antifreeze “Generally Recognized
As Safe” (GRAS) by the FDA must be utilized for antifreeze
and water heating solution.
•
An interlock switch prevents the Aqua-Hot heater from
operating when the cover is not installed in the correct
position.
•
Should any additional assistance be needed, please con-
tact the Product Application Department at +1 (800) 685-
4298 or +1 (303) 651-5500.
•
Do not store or use gasoline or other flammable vapors or
liquids in the vicinity of this or any other appliance
•
Disconnect electric wiring to the Aqua-Hot system before
welding or plasma cutting the RV or home to avoid dam-
age to equipment
•
Air pressure to the tank must NOT exceed 20PSI or it will
cause damage
•
The Aqua-Hot exhaust is HOT and must be kept away from
heat sensitive material
•
Use caution when working on or near the propane gas
system
•
DO NOT connect the 12V DC power to the Aqua-Hot if the
RV or home requires welding
•
At maximum operating temperatures, the coolant will be
very hot and scalding hot vapor or coolant may result in
serious burns or injury
•
DO NOT activate the burner until the antifreeze and water
heating solution has been added to the boiler tank to
avoid serious damage to the heater
WHAT TO DO IF YOU SMELL GAS
•
Evacuate all persons from the vehicle
•
Shut off the gas supply at the gas container or source
•
Do not touch any electrical switch or use any phone or
radio in the vehicle
•
Do not start the engine or electric generator (if equipped)
•
Contact the nearest gas supplier or qualified service tech-
nician for repairs
•
If you cannot contact the nearest gas supplier or qualified
service technician, contact the nearest fire department
•
Do not turn on the gas supply until the gas leak or leaks (if
relevant) has been repaired
•
Installation and service must be performed by a qualified
installer, service agency or gas supplier
The Aqua-
Hot’s exhaust is HOT!
•
Do NOT park in areas where dry conditions exist (i.e.
grassy, dry fields)
•
Do NOT operate the burner inside an enclosed building
•
The heater must be switched OFF when refueling
If the information in these instructions is not followed exact-
ly, a fire or explosion may result causing property damage,
personal injury, or death.
As with any appliance, allow the Aqua-Hot to completely
shut down BEFORE disengaging the coach 12V power dis-
connect.
