Albo marine MG 309, Operation Manual

Page: 14 / 43

4
–4
Model
Power
AC Volts
Battery
Rpm
Fuel
Hz
Class
Ambient
Engine
MG 331
31 kVA
12 V
1500
Diesel
50
H
40 ºC
Kubota V3300 BG
Serial No 333 275
P.F 0,8
113 Amps.
009
220
Yakýt Filtresi
MG 315 - MG 321 - MG 324
MG 331 - MS 315 - MS 321
TG 315 - TG 321 - TG 324
TG 331
Yað Filtresi
MG 315 - MG 321 - MG 324
HH164-32040 MS 315 - MS 321 - MS 324
TG 315 - TG 321 - TG 324
MG 331 - MS 331 - TG 331
HH1CO-32040
V Kayýþý
MG 315 - MG 321 - MS 315
1547197010 MS 321 - TG 315 - TG 321
MG 324 - MS 324 - TG 324 1G953-97010
MG 331 - MS 331 - TG 331 1G521-97010
Ýmpeller
MG 315 - MG 321 - MG 324
2040 MS 315 - MS 321 - MS 321
TG 315 - TG 321 - TG 324
MG 331 - MS 331 - TG 331
2039
Çinko ( Anot ) Tüm Modellerde 3330444
Model Parça No
1663143560
1663143560
1663143560
1663143560
HH164-32040
HH164-32040
1547197010
2040
2040
Genel Bakým
Motor Yað Seviyesi
Su Tutucu Filtre
Akü ve Kutupbaþý Baðlantýlarý
Motor Kayýþý
Sifon Kit
Motor Yað Filtresi
Mazot Filtresi
Çinko ( Anot )
Deniz Suyu Pompasý Ýmpeller
Motor Valve Ayarlarý
Rezervuar Tanký ve Termostat
Alternatör Rulmaný
042
PERÝYODÝK BAKIM PROGRAMI
Günlük ilk çalýþtýrmadan önce ve çalýþtýrmanýn her sekiz saatinden sonra, genel bakým kapsamýnda talimat verildiði gibi jeneratör setini denetleyin.
Yedek Parça
UYARI :
Device
Load
( watts)
Air Conditioner
1400-2000
Battery Charger
Up to 3000
DC Inverter
300-700
Refrigerator
600-1000
Microwave Oven
1000-1500
Toaster
1000-1500
Electric Heater
350-1000
Kettle
1000-1500
Iron
500-1200
Hair Drier
800-1500
Coffee Machine
550-750
TV
200-600
Radio
50-200
Hand Drill
250-750
Vacuum Cleaner
200-500
Electric Blanket
50-200
Lamp
75-100
Deep Freezer
400-1000
TABLE 1. ELECTRIC LOADS OF THE DEVICES
Stopping the Generator Set
Turn off all electrical loads before stopping the
generator. Generator set shall be operated for 2
minutes with no load, then press the “STOP”
button on the Electronic Remote Control Panel.
Engine will stop 5 seconds later.
EMERGENCY STOP BUTTON
When your generator set with cabinet on your
vessel shall be turned off in an emergency
conditions
, press the “Emergency Push Button”
to stop the generators with cabinets. (Figure 7)
For models without cabinets, turn the AC
CIRCUIT BREAKER on the left side of the
control panel to OFF position. After performing
all necessary repairs, turn the emergency stop
switch to “ON” position to allow operation of the
generator set.
LOADING THE GENERATOR SET
Considering that you will use the power
generated by your generator to supply for the
electrical loads of the equipment in your vessel,
check the electrical loads of your equipment in
the sample table below. (Table 1)
Equipment in your vessel shall be precisely
evaluated. If the total used electrical load
determined, you shall select min. 5
–10% more of
this value as the generator output considering
the remaining part as a safety share.
If the electrical load on your vessel exceeds the
generator power, AC CIRCUIT BREAKER FUSE
on the generator is turned “OFF”. To resolve the
faults or negative conditions caused by
overloading, it may be necessary to turn off
some equipment that is supplied by the
generator. After performing this operation while
your generator set is turned off, turn the AC
CIRCUIT BREAKER FUSE “ON” to operate your
generator again.
The sum of the power values (kW) of the
equipment supplied by the generator on your
vessel specified on the product labels or the sum
of the values obtained by the multiplication of the
current (A) values and voltage (V) values shall
not exceed 80-90% of the generator power. After
starting you generator, it would be wise that you
activate the engines, air conditioners or
equipment with higher power first, and then the
equipment with lower powers respectively.
Another important point in generator selection is
that the sum of the instantaneous current load
values of the equipment that will be operated in
your vessel shall not exceed the current values
that your generator may generate.
Generator set is nominal in standard pressure,
humidity and temperature conditions (Ref. ISO
3046). Both low pressure and high ambient
temperature decreases the engine power. It
would be necessary to operate the generator
with lower loads in these conditions.
Emergency Stop Button
FIGURE 7. EMERGENCY STOP BUTTON