Vertiv™ NetSure™ IPE Series -48 VDC Outdoor Rectifier Installation and User Manual
Proprietary and Confidential © 2022 Vertiv Group Corp.
18
1.6.3
Battery Storage Environment
•
Store for 20 days: -20 °C ~ +55 °C
•
Store for 30 days: -20 °C ~ +45 °C
•
Store for 90 days: -20 °C~ +35 °C
When the battery pack needs to be stored for a long time, please charge the battery pack to 80% state, and use the charger to
recharge it every once in a while, according to the storage temperature.
CAUTION!
Due to Li-ion battery shipping regulations, battery shall be typically only charged to 30% SOC. A freshening
charge must be applied in a timely manner, or else damage may occur to cells. SEE MANUFACTURER
RECOMMENDATIONS.
1.6.4
Battery Maintenance
After the battery pack is discharged, the battery must be charged within 48 hours. Otherwise, battery life will be affected. The
battery pack may also be damaged if it is not charged within this time period. If the battery is not used for a long time, remove
the battery and place in a cool, dry environment. Otherwise, the battery may deteriorate.
If the terminals of the battery pack become dirty, wipe them with a dry cloth before use. Otherwise, the battery pack will have
poor contact, causing energy loss or failure to charge.
1.6.5
Precautions for Battery Use
1.
Batteries have ON/OFF switch. Disconnect power at battery via ON/OFF switch until all connections are made.
2.
Do not immerse the battery in water.
3.
Do not approach a heat source.
4.
Do not short-circuit the positive and negative poles of the battery.
5.
Do not reverse charge.
6.
Do not use the battery in an extremely hot environment, such as a closed environment care must be taken to keep
operational temp within -40 °C to +55 °C rating of battery. Otherwise, the battery will overheat and may catch fire
(ignite), which will affect the performance of the battery and shorten the service life of the battery.
7.
DO NOT OPEN THE BATTERY ENCLOSURE due to high hazard inside. Battery is only intended to be replaced, not
repaired if faulty.
8.
If needing replacement, battery must be returned in HAZ MAT approved Class 9 packaging.
9.
It is recommended to store the battery under the conditions in “Battery Storage Environment” above, otherwise it will
reduce battery performance or shorten battery life.
10.
Do not DROP the battery during installation.
11.
Battery maximum elevation – 3000 Meters.
