Sunshine QJ-Y-2-35, Инструкция по эксплуатации

Страница: 36 / 56

35
3
、
Replace the hydraulic oil every 9-10 months. When empty the oil, used oil should
be put clean out. oil level could be in the middle of the oil gauge when filling the oil.
4, Usually should check the oil level, if below the oil gauge should promptly fill oil to
the mid-line.
5,Obstacles is forbidden in oil tank to avoid damages to oil pump.
6
、
Clean up the oil filter every 3 months using Kerosene, hair brush to clean obstacles
on the surface. Be careful not to damage the oil filter, if damaged, should be replaced
immediately
7
、
Steel rope and pulley should be painted lubricant frequently and observe if there's
fracture on the rope, if there should be immediately replaced.
8
、
Check if the column is vertical every 6 months , if vertical change, need to re-adjust,
and tighten the nut, tightening torque of about 80N.M.
5.2 Common faults and solution
No.
faults solution
1
Two sliding table are not
synchronized
Adjust the nuts on the rope (should be regularly
adjusted after usage)
2
Motor doesn't work check whether the power is on
Check whether the power supply is good
and electricity connection is loosen the wiring to fall
off
3
Motor doesn't work The power is not enough