INS_RENEW INS Rev E
Page 45
20 - MAINTENANCE
A. IPI BOARD SYSTEM
The appliance is required to be inspected at least once a year by a professional service person. The compartment below
firebox (behind lower grille) must be cleaned at least once a year; more frequent cleaning may be required due to excessive
lint from carpeting, bedding materials, or other fibrous materials. It is imperative that the burner be cleaned once a year.
•
Annual cleaning of burner system is required.
•
Visually check for blocked port holes, especially
near the pilot. Blocked port holes may cause
delayed ignition.
•
Visually check pilot light and burner when in
operation. Flames should be steady, not lifting or
floating.
B. FAN
The fan should be disconnected from electrical current, and cleaned (vacuumed) every six months. The bearings are sealed
and require no oiling.
C. VENT SYSTEM
•
Annual examination of venting system by a qualified agency is required.
•
IF VENT-AIR INTAKE SYSTEM IS DISASSEMBLED FOR ANY REASON, RE-INSTALL PER INSTRUCTIONS PROVIDED
WITH INITIAL INSTALLATION.
•
The flow of combustion and ventilation air must not be obstructed.
D. GLASS CLEANING & REPLACEMENT
•
Clean glass only when cool and only with non-abrasive cleansers.
•
Do not operate this fireplace with glass/frame assembly removed, cracked or broken.
•
The glass assembly, part #011-044, shall only be replaced as a complete unit, as supplied by Stellar Hearth Products.
•
Replacement of glass & frame assembly, must only be performed by a licensed or qualified service person.
DO NOT SUBSTITUTE MATERIALS.
•
Do not strike or slam glass door assembly.
Figure 20A
Pilot Assembly and Burner Orifice
CAUTION
LABEL ALL WIRES PRIOR TO DISCONNECTION WHEN SERVICING CONTROLS. WIRING ERRORS CAN CAUSE IMPROPER
AND DANGEROUS OPERATION. VERIFY PROPER OPERATION AFTER SERVICING. KEEP APPLIANCE AREA CLEAR
OF COMBUSTIBLE MATERIALS, SUCH AS GASOLINE AND OTHER FLAMMABLE VAPORS AND LIQUIDS. VAPORS AND
LIQUIDS.
IMPORTANT NOTE
ANY SAFETY SCREEN OR GUARD REMOVED FOR SERVICING MUST BE REPLACED PRIOR TO OPERATING THE
APPLIANCE.
IMPORTANT NOTE
INSTALLATION AND REPAIR SHOULD BE DONE ONLY BY QUALIFIED SERVICE PERSON. THE APPLIANCE SHOULD BE
INSPECTED BEFORE USE AND ANNUALLY BY A QUALIFIED SERVICE PERSON. MORE FREQUENT CLEANING MAY BE
REQUIRED DUE TO EXCESSIVE LINT FROM CARPETING, BEDDING MATERIALS, ETC. IT IS IMPERATIVE THAT CONTROL
COMPARTMENTS, BURNERS AND CIRCULATION AIR PASSAGEWAYS OF THE APPLIANCE BE KEPT CLEAN.
