Rayzist 2034vx, Руководство пользователя

Страница: 9 / 20

1/20/2015 (3:46 PM)
2034vx & 2034vxa v6.0.doc
4”
Bag should
rest on the
floor.
2.9 Electrical Connection
2.9.1
Plug cabinet into a grounded 110-120 volt
electrical outlet with 15-amp circuit breaker.
2.9.2
. Turn on power-switch to test proper function
of motor and lights
2.9.3
Check plastic dust bag and make sure it is
collapsing when the dust collector is on.
2.10 Exhaust Connection
2.10.1
The exhaust blower is fitted with a sheet
metal elbow for the purpose of directing the exhaust
in an upward direction. Installation of an exhaust
vent is optional for the purpose of reducing noise or
exhausting dusts resulting from damaged or worn
dust bags. Installation of exhaust vent should be
done by a licensed contractor to make sure there is
no restriction of airflow that would affect the proper
function of the dust collector. Exhausting through a
long vent pipe may require an additional exhaust
fan installed at the point the vent exits the building.
2.11 Adding Abrasive Media
The system has been shipped without the abrasive
media in the pot. Turn the dust collector on, place
unopened 50lb bag of 150 grit aluminum oxide
abrasive into the cabinet. Slit the center of the bag
open. Close the side door and empty the bag using
the front armhole access. After the dust has cleared
remove the bag from the cabinet.
! NOTICE
The abrasive media will break down over time
causing more dust in the cabinet and slower
blasting. New abrasive should never be added to old
abrasive. Instructions for removing worn abrasive
and adding new abrasive are covered in the
Operation Manual. DO NOT over fill the pot with
more than 50 lbs of abrasive; this may prevent the
pot closure cap from sealing.
2.12 Air Compressor Requirements
NOTE: Customer Supplied and used only
for the Cabinet.
The following or similar items are recommended
for moderate cabinet use. www.grainger.com or
call 800 225 5994
1. Air Compressor
Grainger’s Model: # 4YN50
2 horsepower, High Performance Cast Iron Air
Compressor
Free Air CFM @ 90 PSI: 5.5
Free Air CFM @ 135 PSI: 4.9
Volts 60 Hz: 115/230
Amps: 15/7.5
Tank Capacity (Gal): 26
2. Water Trap
3. Air hose