Mr. Heater F242915, Инструкция по эксплуатации и руководство пользователя

Страница: 4 / 24

4
Mr. Heater | Gas-Fired Infra-Red Tank Top Heater Operating Instructions and Owner’s Manual
GENERAL INFORMATION
A. ­­The­MH45T­is­a­high­pressure­propane­appliances­and­is­
designed­to­be­connected­to­a­bulk­propane­tank.­
B. ­­These­heaters­are­equipped­with­an­automatic­Safety­Shutoff­
Valve.­The­gas­flow­will­automatically­stop­if­the­heater­fails­to­
operate­for­any­reason.­
C. ­­Maximum­safety­and­convenience­have­been­built­into­the­Hi-
Med-Lo-Off­Control­Valve/Regulator.­The­following­table­lists­
the­approximate­BTU’s­consumed­and­the­operating­hours­
you­can­reasonably­expect­from­bulk­propane­cylinders.­
D.­This­heater­is­for­temporary­heating­of­buildings­under­
construction,­alterations,­or­repair.
Figure­3.
ODOR FADE WARNING
WARNING
Asphyxiation Hazard
•­ Do­not­use­this­heater­for­heating­human­living­­ ­
quarters.
•­ Do­not­use­in­unventilated­areas.
•­ The­flow­of­combustion­and­ventilation­air­must­­ ­
not­be­obstructed.
•­ Proper­ventilation­air­must­be­provided­to­­ ­ ­
support­the­combustion­air­requirements­of­the­­ ­
heater­being­used.
•­ Refer­to­the­specification­section­of­the­heater’s­­ ­
manual,­heater­dataplate,­or­contact­the­factory­­ ­
to­­determine­combustion­air­ventilation­­ ­ ­
requirements­of­the­heater.
•­ Lack­of­proper­ventilation­air­will­lead­to­­ ­ ­
improper­combustion.
•­ Improper­combustion­can­lead­to­carbon­­ ­ ­
monoxide­poisoning­leading­to­serious­injury­or­­ ­
death.­Symptom­of­carbon­monoxide­poisoning­­ ­
can­include­headaches,­dizziness­and­difficulty­­ ­
in­breathing.
FUEL GAS ODOR
LP gas and natural gas have man-made odorants added
specifically for detection of fuel gas leaks.
If a gas leak occurs you should be able to smell the fuel
gas. Since Propane (LP) is heavier than air you should smell
for the gas odor low to the floor. ANY GAS ODOR IS YOUR
SIGNAL TO GO INTO IMMEDIATE ACTION!
­ •­Do­not­take­any­action­that­could­ignite­the­fuel­gas.­Do­not­
operate­any­electrical­switches.­Do­not­pull­any­power­supply­
or­extension­cords.­Do­not­light­matches­or­any­other­source­
of­flame.­Do­not­use­your­telephone.
­ •­Get­everyone­out­of­the­building­and­away­from­the­area­
immediately.
­ •­Close­all­propane­(LP)­gas­tank­or­cylinder­fuel­supply­valves,­
or­the­main­fuel­supply­valve­located­at­the­meter­if­you­use­
natural­gas.
­ •­Propane­(LP)­gas­is­heavier­than­air­and­may­settle­in­low­
areas.­When­you­have­reason­to­suspect­a­propane­leak,­keep­
out­of­all­low­areas.
­ •­Use­your­neighbor’s­phone­and­call­your­fuel­gas­supplier­and­
your­fire­department.­Do­not­re-enter­the­building­or­area.
­ •­Stay­out­of­the­building­and­away­from­the­area­until­declared­
safe­by­the­firefighters­and­your­fuel­gas­supplier.
­ •­FINALLY,­let­the­fuel­gas­service­person­and­the­firefighters­
check­for­escaped­gas.­Have­them­air­out­the­building­and­
area­before­you­return.­Properly­trained­service­people­must­
repair­any­leaks,­check­for­further­leakages,­and­then­relight­
the­appliance­for­you.
ODOR FADING - NO ODOR DETECTED
•­Some­people­cannot­smell­well.­Some­people­cannot­smell­
the­odor­of­the­man-made­chemical­added­to­propane­(LP)­or­
natural­gas.­You­must­determine­if­you­can­smell­the­odorant­
in­these­fuel­gases.
­ •­Learn­to­recognize­the­odor­of­propane­(LP)­gas­and­natural­
gas.­Local­propane­(LP)­gas­dealers­will­be­more­than­happy­
to­give­you­a­scratch­and­sniff­pamphlet.­Use­it­to­become­
familiar­with­the­fuel­gas­odor.
­ •­Smoking­can­decrease­your­ability­to­smell.­Being­around­
an­odor­for­a­period­of­time­can­affect­your­sensitivity­to­
that­particular­odor.­Odors­present­in­animal­confinement­
buildings­can­mask­fuel­gas­odor.
•­ The odorant in propane (LP) gas and natural gas is
colorless and the intensity of its odor can fade under
some circumstances.
­ •­If­there­is­an­underground­leak,­the­movement­of­gas­through­
the­soil­can­filter­the­odorant.
­ •­Propane­(LP)­gas­odor­may­differ­in­intensity­at­different­
levels.­Since­Propane­(LP)­gas­is­heavier­than­air,­there­may­be­
more­odor­at­lower­levels.
• Always be sensitive to the slightest gas odor. If­you­
continue­to­detect­any­gas­odor,­no­matter­how­small,­treat­
it­as­a­serious­leak.­Immediately­go­into­action­as­discussed­
previously.
ATTENTION - CRITICAL POINTS TO
REMEMBER!
­ •­Propane­(LP)­gas­has­a­distinctive­odor.­Learn­to­recognize­
these­odors.­(Reference­Fuel­Gas­Odor­and­Odor­Fading­
sections­to­the­left­and­above).
­ •­Even­if­you­are­not­property­trained­in­the­service­and­repair­
of­the­heater,­ALWAYS­be­consciously­aware­of­the­odors­of­
propane­(LP)­gas­and­natural­gas.
­ •­If­you­have­not­been­properly­trained­in­repair­and­service­of­
propane­(LP)­gas­then­do­not­attempt­to­light­heater,­perform­
service­or­repairs,­or­make­any­adjustments­to­the­heater­on­
the­propane­(LP)­gas­fuel­system.
­ •­A­periodic­sniff­test­around­the­heater­or­at­the­heater’s­
joints;­i.e.­hose,­connections,­etc.,­is­a­good­safety­practice­
under­any­conditions.­If­you­smell­even­a­small­amount­of­
gas,­CONTACT­YOUR­FUEL­GAS­SUPPLIER­IMMEDIATELY.­DO­
NOT­WAIT!
Actual BTU/HR input rate and fuel consumption times for this
appliance may vary.
1­ ­ Hi­ 15,000­ 23­ 144
1­ ­ Med­ 12,000­ 29­ 180
1­ ­ Lo­ 10,000­ 35­ 216
2­ ­ Hi­ 30,000­ 12­ ­72
2­ ­ Med­ 24,000­ 15­ ­90
2­ ­ Lo­ 20,000­ 18­ 110
3­ ­ Hi­ 45,000­ ­8­ ­48
3­ ­ Med­ 36,000­ ­9­ ­56
3­ ­ Lo­ 30,000­ 12­ ­72
Burners­ ­­­­­Valve­­­­­­­­BTU­Input­­­­­­­­Approximate­Hours­of­Operation
Operating­­­­­Position­­­­­­­­­­­­­­20­Lb.­Cylinder­­­­­100­Lb.­Cylinder