3
WARNING FOR YOUR SAFETY
You must follow all leak-checking procedures before
operating. To prevent fire or explosion hazard when
testing for a leak:
a. Always perform leak test before lighting the grill and
each time the tank is connected for use.
b. Do not use or permit sources of ignition in the area
while conducting a leak test. No smoking.
c. Conduct the leak test outdoors in a well-ventilated
area.
d. Do not use matches, lighters or a flame to check for
leaks.
e. Do not use grill until any and all leaks are corrected.
If you are unable to stop a leak disconnect the LP
gas supply. Call our customer care at
1-866-814-0585, a gas appliance serviceman or
your local LP gas supplier.
Do not use in an explosive atmosphere. Keep grill
area clear and free from combustible materials,
gasoline and other flammable vapors and liquids.
Keep all combustible items and surfaces at least 36
inches (91 cm) away from the grill at all times. DO NOT
use this grill or any gas product under any overhead or
near any unprotected combustible constructions.
It is essential to keep the grill’s valve compartment,
burners and circulating air passages clean. Inspect
grill before each use.
Do not use the grill unless it is COMPLETELY
assembled and all parts are securely fastened and
tightened.
This grill should be thoroughly cleaned and inspected
on a regular basis.
Do not alter grill in any manner. Any alteration will void
your warranty.
Use only the regulator provided. Any replacement
regulator shall be specified by the manufacturer.
Do not use grill in a vehicle trunk, station wagon,
mini-van, sport utility vehicle (SUV) or recreational
vehicle (RV).
When cooking fire extinguishing materials shall be
readily accessible. In the event of an oil/grease fire, do
not attempt to extinguish with water. Use type BC dry
chemical fire extinguisher or smother with dirt, sand or
baking soda.
Move gas hoses as far away as possible from hot
surfaces and dripping hot grease.
Do not use grill in high winds.
Never lean over grill when lighting.
Do not leave a lit grill unattended. Keep children and
pets away from grill at all times.
Do not attempt to move grill when in use. Allow the
grill to cool (approximately 45 minutes) before moving
or storing.
Storage of grill indoors is permissible only if the tank is
disconnected, removed from the grill and properly
stored outdoors.
While wearing a protective glove or mit, open grill lid
carefully and slowly as heat and steam trapped within
grill can severely burn you.
Do not attempt to disconnect the gas regulator from the
tank or any gas fitting while the grill is in use.
Disconnect LP gas tank when not in use.
Always use your grill on a hard, non-combustable, level
surface. An asphalt or blacktop surface may not be
acceptable for this purpose.
Do not use directly on wooden decks.
Keep all electrical cords away from a hot grill.
Do not use grill for indoor cooking or heating. TOXIC
fumes can accumulate and cause asphyxiation.
After a period of storage and/or nonuse check for leaks
and burner obstructions.
Failure to open lid while igniting the grill’s burner, or not
waiting 5 minutes to allow the gas to clear if the grill
does not light, may result in an explosive flame-up.
Never operate grill without heat plate installed. Always
use a meat thermometer to ensure food is cooked to a
safe temperature.
Use protective gloves when assembling this product.
Do not force parts together as this can result in
personal injury or damage to the product.
Never cover entire cooking area with aluminum foil.
Death, serious injury or damage to property may occur
if the above is not followed exactly.
Use only Blue Rhino Global Sourcing, Inc. factory
authorized parts. The use of any part that is not factory
authorized can be dangerous. This will also void your
warranty.
Do not attempt to repair or alter the hose/regulator for
any “assumed” defect. Any modification to this
assembly will void your warranty and create the risk of
a gas leak and fire. Use only authorized replacement
parts supplied by manufacturer.
Do not use this appliance without reading “Operating
Instructions” in this manual.
Do not touch metal parts of grill until it has completely
cooled (about 45 min.) to avoid burns, unless you are
wearing protective gear (pot holders, gloves, BBQ
mittens, etc.).
Do not install or use in or on boats or recreational
vehicles.
