LS LL3301, Руководство пользователя

Страница: 12 / 46

LOADER OPERATION
CAUTION:
The tractor/loader should only be operated
with all safety equipment properly installed.
▶ Precautionary Notes
Do not lower the edge of the bucket too low for
loading. Keep the bottom of the bucket level with
the ground when loading.
▶
Important:
Do not use the bucket for pushing down material
with bucket cylinders partially extended. Damage to
the cylinders may result.
▶
Important:
Do not operate bucket cylinders without bucket, it
may damage to the bucket cylinders.
▶
Important:
Do not tip bucket cutting edge down(fully extended
bucket cylinders) during backfilling/backgrading
operations.
▶
Important:
Operation with front tractor wheels off the ground is
not recommended.
Position vehicle to be loaded as near the pile as
possible and in such a direction as to minimize the
amount of tractor turning required dumping.
Do not lower the loader with the tractor engine shut
off.
Keep the unit clean and perform regular service.
Observe safety messages whenever cleaning,
servicing, or lubricating.
We urge you to follow this advice:
1. Read and understand this manual as well as the
Tractor Operator's Manual.
2. Remember and observe the Safety Precautions
brought to your attention in this manual, the tractor
manual and on the machinery itself.
3. Use good common sense in the everyday
operation of this unit.
Safety recommendations can never be all-inclusive
and you are responsible for watching out for and
avoiding unsafe conditions.
4. Never exceed the limits of a piece of machinery. If
its ability to do a job or to do so safely is in
question, don't try it.
5. Don't hurry the learning process or take the unit
for granted. Ease into it and become familiar with
your new loader and tractor.
CAUTION: When lowering a heavy load, ease
it downward slowly. Never drop a loaded
attachment and "catch it hydraulically".
Stopping a load after it has gained downward
momentum places undue strain on the unit and may
cause unnecessary damage to the loader or tractor
or even worse, personal injury.
CAUTION: Before disconnecting hydraulic
lines, relieve all hydraulic pressure. Escaping
hydraulic oil under pressure can have
sufficient force to penetrate the skin causing serious
personal injury. If injured by escaping hydraulic oil
seek medical attention immediately.
CAUTION: Do not operate the loader if the
fittings are leaking or if the hoses are
damaged. A sudden line burst would cause
the mainframe to drop suddenly, causing damage to
the tractor or loader or injury to personnel.
▶
Initial Loader Operation
Before operating the loader, fully raise and lower the
boom two or three times. Then raise the bucket
approximately four(4) feet above the ground and
cycle the bucket cylinders three times. Lower the
bucket to the ground. Check the tractor hydraulic oil
and the correct oil level.
CAUTION:
Before leaving the machine, stop the engine, remove
the key, place all controls in neutral, and either set
the parking brake or place tractor in park as
equipped.
Always keep cylinders in a retracted position when
the loader is not in use to guard against rust and
contamination which may cause damage to the
cylinder rods or hydraulic system.
▶
Cold Weather Operation
For smooth operation in cold weather, let the tractor
warm up. Slowly cycle the lift and bucket cylinders
several times to warm the oil in the hydraulic system.
The loader may operate erratically until the hydraulic
oil has warmed to operating temperatures.