2
The installation and relocation, if necessary, of this product must be carried out by qualified personnel with
up-to-date safety and hygiene knowledge and practical experience, in accordance with current regulations.
IMPORTANT SAFETY INSTRUCTIONS..........................3
Intended Use..............................................................3
Power Warning...........................................................3
CO
2
Warning...............................................................3
Water Notice...............................................................3
SPECIFICATIONS AND FEATURES...............................4
General System Overview..........................................5
PRE-INSTALLATION CHECKLIST...................................5
INSTALLATION...........................................................6-10
Unpacking the Dispenser............................................6
Selecting/Preparing a Counter Location.....................6
Dispenser Installation..............................................7-8
Installing Remote Syrup Pumps - BIB........................8
Installing CO
2
Supply..................................................9
Adjust Water Flow Rate & Syrup/Water Ratio..........10
SCHEDULED MAINTENANCE......................................11
CLEANING AND SANITIZING..................................11-12
General Information..................................................11
Cleaning and Sanitizing Solutions............................12
Integrity of Plastic Finish...........................................12
Cleaning and Sanitizing Syrup Lines........................12
Cleaning and Sanitizing Nozzles..............................12
TROUBLESHOOTING...............................................13-17
THE ELECTRONIC ICE BANK CONTROL (EIBC).......18
Checking the Normal PCB Operation.......................18
ILLUSTRATIONS AND PART LISTINGS..................20-24
Main Unit Assembly.............................................20-21
Refrigeration Deck Assembly....................................22
Wiring Diagram - 115 Volt.........................................23
Plumbing Diagram....................................................24
SAFETY NOTICES
READ ALL SAFETY INSTRUCTIONS BEFORE USING THIS UNIT.
This manual contains important safety information and all applicable safety precautions must be observed. To reduce
the risk of fire, electric shock, damage to the equipment or personal injury when using this unit all instuctions/warnings
on the product being used must be followed:
Text following the Warning signal indicates a
hazardous situation, which if not avoided, will result
in death or serious injury. Be sure to read all Warning
statements before proceeding with the installation.
!
WARNING
Text following the Caution signal indicates a
hazardous situation, which if not avoided, could result
in death or serious injury. Be sure to read the Caution
statements before proceeding with the installation
!
CAUTION
Text following the Attention signal addresses a
situation that if not followed could potentially damage
the equipment. Be sure to read the Attention
statements before proceeding
!
ATTENTION
Text following the Note signal provides you with
information that may help you more effectively perform
the installation procedures within this manual.
Disregarding information will not cause damage or
injury, however it may limit the performance of the
dispenser.
NOTE
TABLE OF CONTENTS
ABOUT THIS MANUAL
This booklet is an integral and essential part of the product.
Please carefully read the guidelines and warnings contained
herein as they are intended to provide the user with essential
information for the continued safe use and maintenance of the
product. In addition, it provides
GUIDANCE ONLY
to the user
on the correct services and site location of the unit.
BEFORE GETTING STARTED
Each unit is tested under operating conditions and is thoroughly
inspected before shipment. At the time of shipment, the carrier
accepts responsibility for the unit. Upon receiving the unit,
carefully inspect the carton for visible damage. If damage exists,
have the carrier note the damage on the freight bill and file a
claim with carrier. Responsibility for damage to the dispenser
lies with the carrier.
