Kubota Super Series 2 KX 91-3, Руководство оператора

Страница: 79 / 98

59 REGULAR CHECKS AND MAINTENANCE WORK
EVERY 3000 SERVICE HOURS
B
Checking Injection Pump
Consult your local KUBOTA Dealer for this service.
ANNUAL SERVICE
B
Electrical Wiring and Fuses
Check the terminals periodically for proper connections.
Loose wiring or damaged cables can cause improper
functioning or short circuiting of the electrical system.
Check wiring and replace damaged components
immediately. If a fuse blows out soon after having been
replaced, contact your nearest KUBOTA dealer. Do not
use a fuse other than specified.
BIENNIAL SERVICING
To avoid personal injury:
A
Do not loosen the radiator cap before the
radiator has cooled down sufficiently. Then
only loosen the cap and allow enough time for
the pressure in the system to be released. Now
remove the cap completely.
B
Replacing of Radiator Hoses
Replace radiator hoses and hose clamps every two years.
If the hoses are swollen, hard or cracked, they must be
replaced earlier.
B
Changing Radiator Coolant
To avoid personal injury:
A
When using anti-freeze, put on some protection
such as rubber gloves (Anti-freeze contains
poison.).
A
If anti-freeze has been swallowed, seek medical
attention at once.
A
When anti-freeze comes in contact with the
skin or clothing, wash it off immediately.
A Do not mix different types of Anti-freeze. The
mixture can produce chemical reaction
causing harmful substances.
A Anti-freeze is extremely flammable and
explosive under certain conditions. Keep fire
and children away from anti-freeze.
A
When draining fluids from the engine, place
some container underneath the engine body.
A
Do not pour waste onto the grounds, down a
drain, or into any water source.
A
Also, observe the relevant environmental
protection regulations when disposing of anti-
freeze.
A
Anti-freeze if swallowed is poison to people,
animals and birds.
Stop the engine then remove the key and wait until it has
cooled down completely.
1. Open the drain plug on the bottom of the radiator and
drain coolant completely, Should a reserve tank be
equipped, disconnect the line from the tank floor and
then open the drain cock.
2. To clean, rinse the radiator with water.
3. Close the drain plug and fill the radiator and the
reserve tank with coolant fluid. Let the engine idle for
about 5 min., stop the engine and remove the key then
check the coolant level.
(1) Radiator hoses
(2) Hose clamps
(1) Radiator hoses
(2) Hose clamps