![background image](http://html1.mh-extra.com/html/jayco/2016-white-hawk/2016-white-hawk_owners-manual_3567424087.webp)
JAYCO TOWABLE SECTION 7 – FUEL & PROPANE SYSTEMS
7-3
P
ROPANE
G
AS
C
ONTAINER
Propane “container” is a general all inclusive term used to describe a vessel that is used for
storage and delivery of propane gas. The most common of these are:
DOT (Department of Transportation) cylinders are transportable and are commonly used
on recreation vehicles. The capacity of DOT propane cylinders is expressed in pounds.
DOT propane cylinders are required to be removed from the recreation vehicle for filling
and must be filled by weight by a qualified propane facility. DOT Propane cylinders are
equipped with an OPD or Over Fill Protection Device designed to reduce the potential of
overfilling. DOT propane cylinders are also equipped with an ACME service valve that is
for connection of the TYPE 1 ACME pigtail hose assembly to the RV two-stage regulator.
The TYPE 1 ACME pigtail hose assembly is a wrenchless, user friendly, right hand
threaded connector that features a thermally sensitive sleeve and excess flow device. Max
output is 200,000 BTU/hr. It is used to connect propane cylinders to regulators, hoses and
other fittings. It is not for use on gas grills and other low pressure devices. DOT cylinders
equipped with an OPD and ACME type 1 service valve are identified by the triangular
service valve knob.
DOT cylinders are typically marked with “top” or an arrow to indicate the correct
orientation of the cylinder(s). Do not mount, store or transport any cylinder other than the
in proper position indicated.
Be sure to securely re-install DOT cylinder(s) to the recreation vehicle after they have been
removed for filling or replacement. Always close the service valve and install a dust cap
or plug when transporting or storing disconnected containers whether full or empty.
ASME tanks are permanently mounted to the RV and are commonly used on RV motor
homes.
The capacity of ASME tanks is expressed in gallons. ASME tanks are filled while the tank
is tank is attached to the motor home by a qualified propane facility. ASME tanks are
equipped with an automatic stop fill valve designed to reduce the potential of overfilling.
ASME propane tanks are also equipped with a P.O.L. service valve that is for connection
of the supply hose with a left hand threaded brass P.O.L. fitting from the tank service valve
to the two-stage regulator. Not for use on gas grills and other low pressure devices.
NOTE: Tanks are to be installed, fueled and maintained in accordance to State
and Local codes, rules, regulations or laws
.
Propane is a true gas compressed into a liquid form. As the fuel is released from the
container, it changes to vapor which is then used for the operation of the appliances.
Propane will not run through the appliances in the liquid state.
Propane expands 1½ percent for every ten degrees of increase in temperature. It is
imperative to leave sufficient space inside the container to allow for natural expansion of
gas during warmer weather.
The main shut off valve must be kept closed at all times unless you are using the propane
system or filling the propane cylinder. When the cylinder is disconnected from the hose,
install the valve cover that is attached to the container.
WARNING
DOT propane cylinders must be transported and stored in an upright position so the
pressure relief device will function properly. Laying a DOT propane cylinder on its
side may potentially create a very dangerous situation.
Содержание 2016 White Hawk
