HPC EI Series, Инструкция по установке и эксплуатации

Страница: 13 / 45

13
Lighting the Oven
This oven is equipped with an electronic ignition system. This system can operate with 2 D batteries or it
can be used with a 3 volt DC adaptor. The batteries should last between 6months to 1 year depending
on use and where the oven is placed (extreme heat and cold temperatures will decrease the life of the
batteries). Please check battery frequently to make sure its appearance is normal. We recommend
battery replacement every 1 year from time of purchase. HPC Hybrid Oven also has an adaptor that can
be used to electronically ignite the pilot and operate the oven gas burner. This adaptor has to be plugged
in an 110v GFCI outlet.
The oven’s gas burner will not operate unless the safety pilot is on
.
Please follow these steps to turn your burner on:

Make sure burner is clear of ashes or debris.

Make sure valve control valve is on off position.

Turn on valve on LP cylinder or natural gas shut off valve

Turn valve in the oven control panel to off position.

Turn electronic igniter switch to ON. It might take 30 to 60 seconds for gas to travel from tank to
pilot the first time you start your oven)

Once pilot is lit, turn the gas control knob from OFF position slowly to regulate burner flame.

Turn gas regulator knob to OFF and place small pieces of dried hardwood on burner. Regulate
gas flame so wood can ignite. Leave gas on.

Once wood has ignited and smaller pieces of coals have formed, with the back of brush push
wood to center of oven to heat the hearth. Then place more wood on top of coals.

Leave the gas line ON. It will do a couple of things
1. Keep the oven hot and the flame steady
2. Keep the smoke to a minimum
(If you have too much smoke because the fire is dying, wood is wet or not enough wood
– try turning the
gas up a bit, it usually burns off the smoke.)

Your oven should be hot enough to bake a pizza in about 30 min. (obviously cooler temperatures
take a bit longer) the use of our insulating blanket should also help with heat retention.)

Different locations in the oven heat up differently
– The hearth at its hottest temperature gets
around 800°. Inside the dome on top-over 1000°. The outside of dome on left side (where the
burner is lit) can reach about 400° The dome on the opposite side of the burner can reach about
300°.
Gas control knob. Turns flame up or down
Pilot has to be ignited for burner flame.
On/Off switch